Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSVOLKSWAGEN2012JETTA TDI, 4D SEDAN, STANDARD TRANSREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT VARIANT/TRIMSECTION 44 (AIR CONDITIONING (SPORTWAGEN))
2012 Volkswagen Jetta TDI, 4D Sedan, Standard Trans
Section 44 (Air Conditioning (SPORTWAGEN))
2012 Volkswagen Jetta TDI, 4D Sedan, Standard TransSECTION Section 44 (Air Conditioning (SPORTWAGEN))
WARNING: This page is about a different variant/trim than selected.
- 87 Air Conditioning
- General Information
- Description And Operation
- A/C Compressor Sub-Assembly Bracket, Engine Code BRM
- A/C Compressor Sub-Assembly Bracket, Engine Codes BGP And BGQ
- A/C Compressor Sub-Assembly Bracket, Engine Code BPY
- Climatic Control Module Multi-Pin Harness Connectors
- CLIMATRONIC Control Module Multi-Pin Harness Connectors
- CLIMATRONIC A/C Display Control Head Overview
- Condenser
- Expansion Valve
- Passenger Compartment A/C System, Climatic
- Passenger Compartment A/C System, CLIMATRONIC
- Refrigerant Circuit Components Overview
- Specifications
- Diagnosis And Testing
- Removal And Installation
- A/C Compressor
- A/C System Controls, Climatic
- Airflow Door Motor -V71-
- Center Outlet Temperature Sensor -G191-
- Central Air Door Motor -V70-
- Defroster Door Motor -V107-
- Condenser
- Evaporator
- Evaporator Temperature Sensor -G308-
- Flexible Shaft, Climatic
- Fluid Reservoir With Dryer Cartridge
- FOOTWELL Vent Temperature Sensor -G192-
- Fresh Air Blower Control Module -J126-
- Fresh/RECIRCULATION Air Door Motor -V154- / -V425-
- Front A/C Display Control Head -E87- / CLIMATRONIC Control Module -J255-
- Heating And A/C Unit, Climatic
- Heating And A/C Unit, CLIMATRONIC
- High Pressure Sensor -G65-
- Left FOOTWELL Vent Temperature Sensor -G261-
- Left And Right Vent Temperature Sensors
- Left Temperature Door Motor -V158-
- RECIRCULATION Door Motor -V113-
- Right FOOTWELL Vent Temperature Sensor -G262-
- Right Temperature Door Motor -V159-
- Sunlight Photo Sensor -G107- Or Sunlight Photo Sensor 2 -G134-
- Temperature Regulator Door Motor -V68-
- Disassembly And Assembly
- Special Tools
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.