Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
2002 Jaguar X-Type (X400) V6-2.5L
Repair and Diagnosis: Technical Service Bulletins
2002 Jaguar X-Type (X400) V6-2.5LSECTION Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Check Front Axle CV Joint Retention Clips
- Campaign - Reprogram ECM/TCM to Enhance Driveabiltiy
- Campaign - Fuel Tank Inspection/Replacement
- Campaign - Crankcase Breather Valve
- Campaign - Throttle Pedal Stop
- Campaign - Ignition Supply Fuse Change
- Campaign - Headlamp Power Wash Jet Link Replacement
- Recall - Turn Signals Defect Replace GECM
- Campaign - Seat Stabilization Kit Installation
- Campaign - 20 Amp Micro Relay Bad Internal Connection
- Campaign - Cooling Fans Inoperative
- Safety
- Generals
- Customer Interest
- Drivetrain - Driveline Noise
- Engine/A/T - Oil Leak Misdiagnosis
- Fuel/Instruments - Vehicle Empty/Gauge Shows Fuel
- Brakes - Rear Brake Moan/Squeal/Odors
- Steering - Squeaking Noises When Turning Steering Wheel
- Vehicle - Various Squeaks and Rattles
- Suspension - Creak Noise in Rear
- Tires/Wheels - Vibration/Shimmy
- Door Seals - Wind Noise
- Body - Doors Difficult To Close
- Body - Sliding Roof Does Not Close Properly
- Driveline - Whine Noise (Preliminary Checks)
- Driveline - Vibration While Driving
- M/T - Difficulty Engaging 1st or Reverse Gear
- Differential - Booming Noise at 2,900 rpm
- Fuel System - Rough Idle/Hesitation
- Brakes - Gradual Brake Performance Deterioration
- Keyless Entry - Unable To Lock Car Using Key Fob
- Body - Rattle/Squeak From Brake/Clutch Pedal Area
- Emissions - MIL ON, False DTC P0456 EVAP Leak
- Interior - Power Seats Inoperative
- Navigation System - Revised PSE Module
- Navigation System - Telematics(R) Issues
- Instruments - Intermittent/Inoperative Fuel Gauge
- Lighting - Condensation in Headlamps
- Audio System - Popping Noise Upon Brake Application
- Brakes - Chirp/Creak Noise From Rear of Vehicle
- Suspension - Squeak/Creak Noise From Rear of Vehicle
- Engine - MIL ON/Misfire Condition
- Fuel System - Driveabiltiy and Starting Issues
- Body - Trunk Lid Difficult to Close
- Body - Luggage Compartment Lid Inoperative
- Doors - Squeaks and Rattles
- Body - Water Leaks in Luggage Compartment
- Wipers - Squeaking/Streaking/Smearing/Juddering
- Windshield Washer - Reservoir Leak
- Instruments - Interior Rearview Mirror Loose
- A/T - Difficulty Selecting Range
- A/T Scraping Noise At 1,600/1,800 - 2,500 Rpm's
- Wipers/Washers - Headlamp Washer Jet Cover Falls Off
- A/T - Whining Noise From Shift Cables
- Body - Exterior Door Handles When Released
- Body - Exterior Door Handle Stiff or Inoperative
- A/C/Body - Water Leaks Onto Passenger Floor
- Brakes - Malfunctioning Brake Vacuum Pump Removal
- Brakes - Excessive Travel of Parking Brake Lever
- Drivetrain - Rear Differential Whine Noise
- Interior - Front Seat Rocking Motion
- Message Center - Incorrect Fuel Range Indicated
- Keyless Entry - Remote Transmitter Won't Function
- Body - Luggage Compartment Lid Doesn't Open Properly
- A/C, Interior - Passenger Seat Heater Int. Inoperative
- Drivetrain - Tranfer Case Rear Output Flange Oil Leak
- Engine - Hesitation/Hissing Noise/DTC P0171/P0174
- A/C - Windows Fogging/Slow to Cool/Blend Door Loose
- Interior - Premature Front Seat Backrest Wear
- Ignition System - MIL ON/DTC's P0341/P1341
- Body - Front/Rear Door Glass Won't Close All The Way
- M/T - Rattle From The Clutch Area at Idle
- Drivetrain - Transfer Case Oil Leak
- A/C - Windshield Heater is Inoperative
- Suspension - Front End Creak When Braking On Bumps
- Body - Interior/Exterior Door Handle Binds/Stiff/Squeaks
- Electrical - MIL ON/Misfire DTC's Set
- Body - Rust Beneath Trunk Lid Trim Panel
- Engine - Knocking at 1,000-2,300 RPM Under a Light Load
- Cooling System - Leaks From Coolant Expansion Tank
- Body - Quarter Glass Trim Is Loose
- Power Steering System - Squeaking Noises
- Steering - Power Steering Leak/Heavy/Noisy Diagnostics
- Suspension - Front End Knocking Noises
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- A/C - Does Not Cool Sufficiently
- Body - Front Door Window Complaints
- Engine Controls - MIL ON/DTC P1254 Set
- Superceded Bulletins
- XT204-04 - 12/01/04
- XT211-0015 - 03/01/06
- XT211-0014 - 02/14/06
- XT211-0013 - 01/30/06
- XT211-0012 - 01/22/06
- XT211-001 - 01/01/06
- XT204-08 - 04/01/05
- XT303-11 - 12/01/03
- XT211-01 - 02/01/06
- XT501-21 - 10/01/04
- XT310-05 - 02/01/05
- XT211-01 - 02/01/04
- XT501-04 - 04/01/02
- XT307-01 - 2001/08/01
- XT303-S939 - 05/01/03
- XT303-S928 - 2002/10/01
- 6-96 - 12/01/01
- Interior - Seat Moves During Acceleration/Deceleration
- Interior - Driver's Seat Rocks on Acceleration/Braking
- Body/Frame - Sliding Roof Does Not Close Properly
- Body - Rear Quarter Window Trim loose
- Trunk Lid - Difficult to Close
- Body - Wind Noise From Top of Door Window
- Body - Front Door Glass Won't Fully Close/Rattles
- Body - Exterior Door Handle Stiff/Inoperative
- Campaign - GECM Module Replacement
- Keyless Entry - Remote Transmitter Inoperative
- Recall - Air Bag Control Module Reprogramming
- Suspension - Revised Control Arm Removal/Installation
- Suspension - Creaking Noise on Speed Bumps
- Steering - Servotronic(R) Power Steering Squeaking Noise
- Brakes - DSC Lamp ON/DTC U1900 Stored in Memory
- M/T - Shift Cable Whining Noise
- Driveline - Drive Shaft Vibration Diagnosis and Repair
- Driveshaft - Vibration Diagnosis/Repair
- Campaign - A/T Replacement
- Instruments - Intermittent Fuel Gauge Operation
- Dynamic Stability Control - Lamp ON/DTC U1900 Set
- Engine Controls - Removing Seized O2 Sensors
- Steering - Squeaking Noises
- Power Steering - Squeaking Noise
- Interior - Water Leaks Into Passenger Footwell Area
- All Technical Service Bulletins
- Body/Frame - Squeaks and Rattle Kit Availability
- Interior - Overhead Console Switch Availability
- Vehicle - Squeak and Rattle Service Kit
- Warranty - Re-acquired Coverage
- JTIS Workshop Manual - CD-ROM
- Drivetrain - Driveline Noise
- Engine/A/T - Oil Leak Misdiagnosis
- Fuel/Instruments - Vehicle Empty/Gauge Shows Fuel
- Brakes - Rear Brake Moan/Squeal/Odors
- Steering - Squeaking Noises When Turning Steering Wheel
- Steering - Fluid Reservoir Replacement Criteria Update
- Vehicle - Various Squeaks and Rattles
- Suspension - Creak Noise in Rear
- Tires/Wheels - Vibration/Shimmy
- Body - Door Locking and Unlatching Diagnosis
- Door Seals - Wind Noise
- Body - Doors Difficult To Close
- Body - Sliding Roof Does Not Close Properly
- Driveline - Whine Noise (Preliminary Checks)
- Campaign - Check Front Axle CV Joint Retention Clips
- Driveline - Vibration While Driving
- M/T - Difficulty Engaging 1st or Reverse Gear
- Differential - Booming Noise at 2,900 rpm
- Drivetrain - Transfer Case Removal Procedure Update
- M/T - Clutch Slave Cylinder Installation Precautions
- Fuel System - Rough Idle/Hesitation
- ECM - DTC P1582 Data Clarification
- Brakes - Gradual Brake Performance Deterioration
- Keyless Entry - Unable To Lock Car Using Key Fob
- Body - Rattle/Squeak From Brake/Clutch Pedal Area
- Engine Control - MIsfire/Hestation When Cold
- Emissions - MIL ON, False DTC P0456 EVAP Leak
- Campaign - Reprogram ECM/TCM to Enhance Driveabiltiy
- Campaign - Fuel Tank Inspection/Replacement
- Fuel System - Fuel Tank Removal/Installation Procedure
- Fuel System - DO NOT CLEAN Electronic Throttle Body
- Campaign - Crankcase Breather Valve
- Campaign - Throttle Pedal Stop
- Interior - Power Seats Inoperative
- Navigation System - Revised PSE Module
- Navigation System - Telematics Concerns/Latest Software
- Navigation System - Telematics(R) Issues
- Interior - Sun Visor Bulb Replacement
- Campaign - Ignition Supply Fuse Change
- Instruments - Intermittent/Inoperative Fuel Gauge
- Lighting - Condensation in Headlamps
- Audio System - Popping Noise Upon Brake Application
- Brakes - Chirp/Creak Noise From Rear of Vehicle
- Brakes - Revised Parking Brake Cable Adjustment Spec.
- Suspension - Squeak/Creak Noise From Rear of Vehicle
- Anti-Theft System - (PATS) Diagnostic Flowcharts
- Emissions System - EVAP System Diagnostic Flow Charts
- WDS - JTP 759/13 Software
- Engine - MIL ON/Misfire Condition
- Engine Control - MIL ON, Driveability Issues
- Engine Control - Diagnostic Flow Charts
- Fuel System - Driveabiltiy and Starting Issues
- Body - Trunk Lid Difficult to Close
- Body - Luggage Compartment Lid Inoperative
- Doors - Squeaks and Rattles
- Body - Water Leaks in Luggage Compartment
- Wipers - Squeaking/Streaking/Smearing/Juddering
- Windshield Washer - Reservoir Leak
- Instruments - Interior Rearview Mirror Loose
- A/T - Difficulty Selecting Range
- A/T Scraping Noise At 1,600/1,800 - 2,500 Rpm's
- Suspension - Front Control Arm R and I Time Revision
- Wipers/Washers - Headlamp Washer Jet Cover Falls Off
- Campaign - Headlamp Power Wash Jet Link Replacement
- A/T - Whining Noise From Shift Cables
- Restraint System - Flash Codes and PID Code Definitions
- Recall - R935 Turn Signal Indicator
- Recall - Turn Signals Defect Replace GECM
- Navigation System - Exchange Program
- GPS System - Window Tint Disrupts Signal
- Navigation System - Diagnostic Procedures
- Body - Exterior Door Handles When Released
- Body - Exterior Door Handle Stiff or Inoperative
- A/C/Body - Water Leaks Onto Passenger Floor
- Brakes - Malfunctioning Brake Vacuum Pump Removal
- Brakes - Excessive Travel of Parking Brake Lever
- Recall 04V487000: Park Brake Lever Replacement
- Recall - Park Brake Lever Replacement
- Recall 03V011000: Rear Turn Signals Inoperative
- Campaign - Circuit Failure/GECM Module Replacement
- Drivetrain - Rear Differential Whine Noise
- Interior - Front Seat Rocking Motion
- Campaign - Seat Stabilization Kit Installation
- Message Center - Incorrect Fuel Range Indicated
- Keyless Entry - Remote Transmitter Won't Function
- Keyless Entry - Remote Transmitter Programming
- Body - Luggage Compartment Lid Doesn't Open Properly
- A/C, Interior - Passenger Seat Heater Int. Inoperative
- Drivetrain - Tranfer Case Rear Output Flange Oil Leak
- Engine - Hesitation/Hissing Noise/DTC P0171/P0174
- Steering/Suspension - Alignment Toe Specification Change
- A/C - Windows Fogging/Slow to Cool/Blend Door Loose
- Campaign - 20 Amp Micro Relay Bad Internal Connection
- Interior - Premature Front Seat Backrest Wear
- Campaign - Cooling Fans Inoperative
- ABS/TCS - Sensor Cluster Diagnostics
- Ignition System - MIL ON/DTC's P0341/P1341
- Body - Front/Rear Door Glass Won't Close All The Way
- Interior - Approved Cleaning Products
- M/T - Rattle From The Clutch Area at Idle
- Drivetrain - Transfer Case Oil Leak
- ABS/TCS - Wheel Speed Sensor Diagnostics
- Brakes - ABS Module CAN Fault Diagnosis
- Brakes - ABS Module Fault Diagnostics
- A/C - Windshield Heater is Inoperative
- Suspension - Front End Creak When Braking On Bumps
- Body - Interior/Exterior Door Handle Binds/Stiff/Squeaks
- Electrical - MIL ON/Misfire DTC's Set
- Body - Rust Beneath Trunk Lid Trim Panel
- Body - Windshield Damage Diagnostic Guide
- Engine - Knocking at 1,000-2,300 RPM Under a Light Load
- Instruments - Instrument Cluster Diagnostics
- Cooling System - Leaks From Coolant Expansion Tank
- Body - Quarter Glass Trim Is Loose
- Power Steering System - Squeaking Noises
- Steering - Power Steering Leak/Heavy/Noisy Diagnostics
- Steering - Revised Steering Gear Removal/Installation
- Engine Controls - Removal of Seized Oxygen (O2) Sensors
- Suspension - Front End Knocking Noises
- A/T - Revised Removal/Installation Procedure
- M/T - Revised Removal/Installation Procedure
- Suspension - Rear Underbody Noise
- Keyless Entry - Can't Lock Vehicle Using Remote Fob
- Engine - Aluminum Thread Repair Information
- Body - Revised Front Door Lock Actuator/Cable Service
- Drivetrain - Revised Transfer Case Output Seal Service
- Recall - Restraint Control Module Programming
- A/C - Does Not Cool Sufficiently
- Campaign - CAMPAIGN CLOSED, Repair Still Valid
- Body - Front Door Window Complaints
- Engine Controls - MIL ON/DTC P1254 Set
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.