Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSFORD2010TRANSIT CONNECT VAN CARGOREPAIR AND DIAGNOSISENGINE PERFORMANCETESTING & DIAGNOSISENGINE CONTROLS - SYMPTOM CHARTS (EXCEPT DIESEL & HYBRID)NO DIAGNOSTIC TROUBLE CODES (DTCS) PRESENT SYMPTOM CHART INDEX
2010 Ford Transit Connect Van Cargo
No Diagnostic Trouble Codes (DTCs) Present Symptom Chart Index
2010 Ford Transit Connect Van CargoSECTION No Diagnostic Trouble Codes (DTCs) Present Symptom Chart Index
DRIVEABILITY SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| Starting Concerns | Hard Start/Long Crank/Erratic Start/Erratic Crank | 602300 | CHART NUMBER: 2 |
| No crank | 601300 | CHART NUMBER: 22 | |
| No start (engine cranks) | 603300 | CHART NUMBER: 3 | |
| Unique Idle Concerns | Slow return to idle | 617400 | CHART NUMBER: 4 |
| Rolling idle | 618400 | CHART NUMBER: 1 | |
| Fast idle | 619400 | CHART NUMBER: 5 | |
| Low/Slow idle | 607400 | CHART NUMBER: 6 | |
DRIVEABILITY SYMPTOM CHART - PERFORMANCE WHILE DRIVING CONCERNS
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| Stalls/Quits | Idle/Acceleration/Cruise | 607x00 | CHART NUMBER: 1 |
| Deceleration | 607700 | CHART NUMBER: 6 | |
| Stall after start | 607000 | CHART NUMBER: 1 | |
| Runs Rough | 608x00 | CHART NUMBER: 1 | |
| Misses | 609x00 | CHART NUMBER: 1 | |
| Buck/Jerk | 610x00 | CHART NUMBER: 1 | |
| Hesitation/Stumble | 611x00 | CHART NUMBER: 1 | |
| Surge | 612x00 | CHART NUMBER: 1 | |
| Backfires | 613x00 | CHART NUMBER: 7 | |
| Lack/Loss of Power | 614x00 | CHART NUMBER: 8 | |
| Spark Knock | 615x00 | CHART NUMBER: 9 | |
|
NOTE:
OASIS identifiers (the x means any number (1-9) can be used) xxx4xx equals during idle, xxx5xx equals during acceleration, xxx6xx equals during cruise, xxx7xx equals during deceleration.
|
|||
ADDITIONAL DRIVEABILITY CONCERNS SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number |
|---|---|---|
| Diesels/Runs On | 621000 | CHART NUMBER: 5 |
| Poor Fuel Economy | 622000 | CHART NUMBER: 10 |
| Emissions Compliance | 623000 | CHART NUMBER: 11 |
ELECTRICAL SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| Warning Indicators | Malfunction indicator lamp (MIL) | 698298 | CHART NUMBER: 12 |
| Transmission control indicator lamp (TCIL) | 698298 | CHART NUMBER: 12 | |
| Power take off (PTO) | 507000 | CHART NUMBER: 12 | |
| Temperature warning indicator or gauge (for vehicles equipped with a cylinder head temperature (CHT) sensor only) | 206000 | CHART NUMBER: 12 | |
| Check fuel cap indicator | 206000 | CHART NUMBER: 12 | |
| Powertrain malfunction indicator (wrench) | 698298 | CHART NUMBER: 12 | |
| Instrumentation | Tachometer inoperative | 204000 | CHART NUMBER: 14 |
| Speedometer/odometer inoperative | 204000 | CHART NUMBER: 14 | |
| Boost gauge indicates higher than normal boost | 204000 | CHART NUMBER: 14 | |
| Fuel gauge inoperative | 204000 | CHART NUMBER: 14 | |
ENGINE SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| Oil System Concerns | High oil consumption | 401000 | CHART NUMBER: 15 |
| Leaks | 401000 | CHART NUMBER: 15 | |
| Cooling System Concerns | Electric cooling fan(s) does not operate (low, high or variable speed) | 402000 | CHART NUMBER: 16 |
| Cooling fan clutch does not operate | 402000 | CHART NUMBER: 16 | |
| Electric cooling fan(s) always runs | 402000 | CHART NUMBER: 17 | |
| Exhaust System Concerns | Visible smoke | 403000 | CHART NUMBER: 18 |
| Odor (sulfur or rotten egg smell) | 403000 | CHART NUMBER: 21 | |
| Fuel System Concerns | Odor, engine compartment | 404000 | CHART NUMBER: 19 |
| Engine Noise (under hood) | 497000 | CHART NUMBER: 20 | |
DRIVELINE SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| Automatic Transmission (A/T) Shift Concerns | Upshift | 501000 | CHART NUMBER: 1 |
| Downshift | 502000 | CHART NUMBER: 1 | |
| Engagement | 503000 | CHART NUMBER: 1 | |
POWER TAKE OFF (PTO) SYMPTOM CHART
| System/Symptom | Oasis Number | Chart Number | |
|---|---|---|---|
| PTO Concerns | Not working correctly | 507000 | CHART NUMBER: 12 |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.