Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2006SUBURBAN K2500, 6.0 UREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 219 (POWER STEERING SYSTEM)
2006 Chevrolet Suburban K2500, 6.0 U
Section 219 (Power Steering System)
2006 Chevrolet Suburban K2500, 6.0 USECTION Section 219 (Power Steering System)
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2003 GMC Savana Special, 2003 GMC Savana Camper Special, 2003 GMC Savana, 2003 Chevrolet RV Cutaway, and 2003 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Component Locator
- Diagnostic Information And Procedures
- Diagnostic Starting Point - Power Steering System
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System
- Whine or Growl Noise from the Power Steering System
- Steering Effort Hard in One or Both Directions
- Steering Effort Too Easy in One or Both Directions
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Flushing the Power Steering System
- Remote Power Steering Fluid Reservoir Replacement
- Power Steering Pulley Replacement
- Power Steering Pump Replacement (4.3L)
- Power Steering Pump Replacement (4.8L, 5.3L, and 6.0L)
- Power Steering Reservoir Replacement - Off Vehicle
- Power Steering Pump Flow Control Valve Replacement - Off Vehicle
- Pitman Shaft Seal Replacement - On Vehicle (Non Rack and Pinion)
- Tie Rod Replacement - Inner - On Vehicle
- Tie Rod End Replacement - Outer
- Rack and Pinion Boot Replacement - On Vehicle
- Power Steering Cooler Pipe/Hose Replacement (GT4)
- Power Steering Cooler Pipe/Hose Replacement (GT5)
- Power Steering Reservoir Inlet Pipe/Hose Replacement
- Power Steering Reservoir Outlet Pipe/Hose Replacement
- Power Steering Gear Outlet Hose Replacement
- Power Brake Booster Inlet Hose Replacement
- Power Brake Booster Outlet Hose Replacement
- Power Steering Gear Replacement (Non-Rack and Pinion)
- Power Steering Gear Replacement (Rack and Pinion)
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle (Rack and Pinion)
- Rack and Pinion Boot and Breather Tube Replacement - Off Vehicle
- Tie Rod Replacement - Inner (Quiet Valve)
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Stub Shaft Seals and Bearing Replacement - Off Vehicle
- Worm Thrust Bearing Preload Adjustment - Off Vehicle (700 Gear)
- Pitman Shaft Over-Center Preload Adjustment - Off Vehicle (700 Gear)
- Steering Gear Pitman Shaft and Housing Cover Replacement - Off Vehicle (700 Gear)
- Steering Gear Housing End Plug Replacement - Off Vehicle
- Steering Gear Valve Replacement - Off Vehicle (700 Gear)
- Rack Piston and Worm Shaft Replacement - Off Vehicle (700 Gear)
- Pitman Shaft Seals and Bearing Replacement - Off Vehicle (700 Gear)
- Steering Gear Check Valve Replacement - Off Vehicle
- Steering Gear Thrust Support Replacement - Off Vehicle (700 Gear)
- Description and Operation
- Special Tools and Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.