Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSVOLKSWAGEN2009NEW BEETLE (1C1) L5-2.5L (BPS)REPAIR AND DIAGNOSISLIGHTING AND HORNSHEADLAMPLOCATIONSHID HEADLAMPS SYSTEM ASSEMBLY OVERVIEW
2009 Volkswagen New Beetle (1C1) L5-2.5L (BPS)
HID Headlamps System Assembly Overview
2009 Volkswagen New Beetle (1C1) L5-2.5L (BPS)SECTION HID Headlamps System Assembly Overview
Comfort System
HID Headlamps System Assembly Overview
Component A is not shown in the overview
A - Headlamp Washer Pump -V11- => [ Headlamp Washer Pump ] See Image Below.
1 - Left High-intensity Gas Discharge Lamp Control Module -J343- /Right High-intensity Gas Discharge Lamp Control Module -J344-
• Integrated with headlamp unit
• Modules cannot be replaced separately; replace complete headlamp housing
2 - Left Front Level Control System Sensor -G78- => [ Left Front Level Control System Sensor ] See Image Below.
3 - Left Rear Level Control System Sensor -G76- => [ Left Rear Level Control System Sensor ] See Image Below.
4 - Headlamp Range Control Module
• Left Headlamp Range Control Module -J567- => [ Left Headlamp Range Control Module ] See Image Below.
• Left Headlamp Range Control Module is located in the left front wheel housing
• Right Headlamp Range Control Module -J568- => [ Right Headlamp Range Control Module ] See Image Below.
• Right headlamp range control module located in the right front/inner long member
5 - Headlamp housing
9 - High Intensity Gas Discharge (HID) lamp
10 - Left Headlamp Beam Adjustment Motor -V48- /Right Headlamp Beam Adjustment Motor -V49- => [ HID Headlamp Beam Adjustment Motor ] See Image Below.
Left Rear Level Control System
Sensor
- Left Rear Level Control System Sensor -G76-
Left Front Level Control System
Sensor
- - Left Front Level Control System Sensor -G78-
Left Headlamp Range Control Module
- - Left Headlamp Range Control Module -J567-
Right Headlamp Range Control Module
- - Right Headlamp Range Control Module -J568-
HID Headlamp Beam Adjustment Motor
- - Left Headlamp Beam Adjustment Motor -V48- /Right Headlamp Beam Adjustment Motor -V49-
Headlamp Washer Pump
4 - To the pump for headlamp wash/wipe system - V11
10 - Headlamp Washer Pump -V11-
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.