Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSSUZUKI2009EQUATOR SPORT, 4D PICKUP EXTRA CAB, 4WDREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 41 (FUEL SYSTEM)
2009 Suzuki Equator Sport, 4D Pickup Extra Cab, 4WD
Section 41 (Fuel System)
2009 Suzuki Equator Sport, 4D Pickup Extra Cab, 4WDSECTION Section 41 (Fuel System)
WARNING: This page is about a different car, the 2007 Suzuki XL7. However, it is still accessible from the selected car via links, so may be relevant.
- Precautions
- General Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Primary Fuel Tank Module
- Secondary Fuel Tank Module
- Fuel Pump
- Primary and Secondary Jet Pumps
- Fuel Sender Strainers
- Fuel Filter
- Fuel Pressure Regulator
- On-Board Refueling Vapor Recovery (ORVR) System
- EVAP Lines and Hoses
- Fuel Rail
- Fuel Injectors
- Fuel Pump Relay
- Engine Fueling
- Sequential Fuel Injection (SFI)
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Shut-Off Mode
- Fuel System Description
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Controls
- Scan Tool Output Controls - Engine Controls - 3.6L (LY7)
- Scan Tool Data List - Engine Controls - 3.6L (LY7)
- Scan Tool Data Definitions - Engine Controls - 3.6L (LY7)
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Solenoid Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (w/o Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (w/ Special Tool)
- Repair Instructions
- Fuel Pressure Relief (With J 34730-1A)
- Fuel Pressure Relief (Without J 34730-1A)
- Fuel Pressure Gauge Installation and Removal
- Metal Collar Quick Connect Fitting Service
- Plastic Collar Quick Connect Fitting Service
- Fuel Feed Pipe Replacement
- Fuel Injector and Fuel Rail Replacement
- Fuel Tank Draining
- Filler Tube Replacement
- Fuel Tank Replacement (FWD)
- Fuel Tank Replacement (AWD)
- Fuel Tank Pressure Sensor Replacement
- Primary Fuel Tank Module Replacement
- Secondary Fuel Tank Module Replacement
- Primary Fuel Level Sensor Replacement
- Fuel Level Sensor Replacement - Secondary
- Fuel Tank Filler Vent Hose Replacement
- Fuel System Cleaning
- Specifications
- Special Tools and Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.