Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSMINI2013COOPER JCW, 2D CONVERTIBLE, STANDARD TRANSREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 3714 (HEATING AND AIR CONDITIONING - REPAIR)
2013 Mini Cooper JCW, 2D Convertible, Standard Trans
Section 3714 (Heating And Air Conditioning - Repair)
2013 Mini Cooper JCW, 2D Convertible, Standard TransSECTION Section 3714 (Heating And Air Conditioning - Repair)
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2016 BMW 760Li, 2015 BMW 760Li, 2014 BMW 760Li, 2013 BMW 760Li, and 2012 BMW 760Li. However, it is still accessible from the selected car via links, so may be relevant.
- General
- Heater With Operation
- 64 11... Installing servodrive
- 64 11.. Overview of actuator drives on heater/air conditioner
- 64 00.. Overview of heater - A/C system components
- 64 11 545 Removing and installing blower housing for heating and air-conditioning unit
- 64 11 377 Removing and installing control panel of heater/air conditioning system
- 64 11 973 Removing and installing or replacing ozone generator (before 09/2010)
- 61 31 321 Removing and installing radio and A/C control panel
- 64 11... Removing and installing rear heater / air conditioning controls
- 64 11 794 Removing and installing/renewing controller for rear cabin fan
- 64 11 906 Removing and installing/renewing ventilation temperature sensor (center fresh air grille)
- 64 11 868 Removing and installing/replacing actuator drive for defrosting flap
- 64 11 262 Removing and installing/replacing auxiliary water pump
- 64 0... Disconnecting a water hose
- 64 11 198 Removing and installing/replacing complete rear air conditioner
- 64 11 395 Removing and installing/replacing control panel for rear cabin A/C system
- 64 51 530 Removing and installing/replacing expansion valve for rear air conditioner
- 64 11 213 Removing and installing/replacing heater/air conditioner fan
- 64 11 206 Removing and installing/replacing heating and air-conditioning unit
- 64 11 263 Removing and installing/replacing rear compartment blower
- 64 11 991 Removing and installing/replacing sensor for automatic air recirculation control (AUC)
- 64 11 879 Replace control panel for heater/air conditioning system
- 64 11 819 Replacing actuator drive for fresh air/ram air
- 64 11 835 Replacing actuator drive for left blending flap
- 64 11 840 Replacing actuator drive for left footwell flap
- 64 11 822 Replacing actuator drive for left rear cabin blending flap
- 64 11 857 Replacing actuator drive for left rear cabin footwell flap (High A/C system)
- 64 11 830 Replacing actuator drive for middle left ventilation flap (High A/C system)
- 64 11 832 Replacing actuator drive for middle right ventilation flap (High A/C system)
- 64 11 827 Replacing actuator drive for outer left ventilation flap
- 64 11 831 Replacing actuator drive for outer right ventilation flap
- 64 11 865 Replacing actuator drive for recirculated air flap
- 64 11 841 Replacing actuator drive for right footwell flap
- 64 11 823 Replacing actuator drive for right rear cabin air blending flap
- 64 11 858 Replacing actuator drive for right rear cabin footwell flap (High A/C system)
- 64 11 837 Replacing actuator drive for right stratification flap
- 64 11 216 Replacing blower for automatic rear air-conditioning system
- 64 11 903 Replacing control panel for rear compartment air conditioning, left (right)
- 64 11 225 Replacing controller for heating and A/C system blower
- 64 11 229 Replacing controller for rear air conditioning blower
- 64 11 540 Replacing distributor housing at top for heating and air-conditioning unit
- 64 11 943 Replacing evaporator temperature sensor
- 64 11 208 Replacing heat exchanger
- 64 11 532 Replacing heat exchanger (heating and air-conditioning unit removed)
- 64 11 902 Replacing interior temperature sensor blower (A/C control panel)
- 64 11 889 Replacing interior temperature sensor blower (rear air conditioning control unit)
- 64 11 786 Replacing left blinds actuator drive
- 64 11 788 Replacing left flap actuator drive
- 61 35 180 Replacing rear air conditioning control unit
- 64 11... Replacing rear passenger compartment A/C control panel fan motor
- 64 11 787 Replacing right blinds actuator drive
- 64 11 789 Replacing right flap actuator drive
- 64 11 951 Replacing temperature sensor for heater
- 64 11 273 Replacing water valve for heater (N74)
- Auxiliary Heater With Control Elements
- 64 12... Initializing Telestart hand-held transmitter
- 64 00.. Overview of heater - A/C system components
- 64 12 160 Removing and installing or replacing complete independent heater with bracket
- 64 12 600 Removing and installing or replacing fuel pump
- 64 12 089 Removing and installing or replacing silencer
- 64 12 580 Removing and installing/replacing exhaust pipe
- 64 12 120 Removing and installing/replacing intake silencer for independent/auxiliary heater
- 64 12 577 Replacing changeover valve for independent/auxiliary heating
- 64 12 670 Replacing electric auxiliary heater - front-
- 64 12 673 Replacing left or right electric auxiliary heater - rear cabin
- 64 12 681 Replacing temperature sensor for left or right electric auxiliary heating - rear passenger compartment
- 64 12 570 Replacing turbocharger coolant pump for auxiliary heating
- Nozzles And Outlets
- 64 00.. Overview of heater - A/C system components
- 64 22 137 Removing and installing or replacing left fresh-air grille
- 64 22 190 Removing and installing/renewing rear compartment fresh-air grille (Basic A/C system)
- 64 22 165 Removing and installing/replacing center fresh air grille
- 64 22... Removing and installing/replacing fresh-air grille on left or right B-pillar
- 64 22 720 Removing and installing/replacing headlining fresh air grille
- 64 22 191 Removing and installing/replacing rear cabin fresh-air grille (High A/C system)
- 64 22 138 Removing and installing/replacing right fresh-air grille
- MICROFILTER
- Air Conditioning System
- 64 50... A/C performance test (R 134a)
- 64 50 010 Drawing off, evacuating and filling heating and air conditioning system (R134a)
- 64 50... Instructions for handling R 134a refrigerant
- 64 50... Leak detection with forming gas
- 64 50... Leak detection with ultraviolet additives (UV additives) (BMW leak-testing case)
- 64 00.. Overview of heater - A/C system components
- 64 50... Safety information for handling refrigerant oil
- 64 50... Safety information for handling tetrafluorethane refrigerant R134a
- Ac Housing/Evaporator, Switching Elements
- 64 51 001 Cleaning evaporator
- 64 51... Leak-testing evaporator
- 64 00.. Overview of heater - A/C system components
- 64 51 525 Removing and installing or replacing expansion valve
- 64 51 591 Removing and installing/renewing evaporator
- 64 51 600 Removing and installing/replacing evaporator for rear air conditioner
- 64 51 530 Removing and installing/replacing expansion valve for rear air conditioner
- Compressor
- Condenser And Dryer With Lines
- 64 53... Instructions for desiccant insert replacement
- 64 53... Instructions for replacement of air conditioning capacitors and radiator/coolers
- 64 53 761 Intake pipe from connecting piece to automatic rear air-conditioning system
- 64 00.. Overview of heater - A/C system components
- 64 53 761 Pressure line from connecting piece to rear heater - A/C system
- 64 53 551 Removing and installing/replacing capacitor for air conditioning system (N74)
- 64 53 518 Replacing desiccant insert for A/C system (capacitor removed)
- 64 53 517 Replacing desiccant insert for air conditioning system
- 64 53 521 Replacing safety pressure switch (N74)
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.