Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2013 Mini Cooper Base, 2D Convertible, Automatic TransFACTORY OEM SERVICE PROCEDURE
Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Bonnet, Boot & Wings: 41ST Edition (SI M06 05 17)
- Tool Rental Program (SI M04 05 17)
- BLUETOOTH Connection Failures (SI M84 01 14)
- Integrated Measurement Interface Box - IMIB R2 V6 (M07 01 16)
- IPHONE And IOS 8.X Information (SI M84 01 15)
- Test Kit For Electrical Contacts (M04 01 13)
- Crimping Pliers For Wire End Ferrules (M04 13 12)
- Mini Output Shaft Adapter Kit For Use With Hydraulic Wheel Bearing And Output Shaft Tool (M04 06 12)
- Workshop Efficiency Mobile Toolbox (M04 11 12)
- Cable Set For Test Box (M04 04 12)
- Mini Special Tool Storage Cabinet (M04 02 12)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Accessories Control Systems
- USB Cable: Battery Discharge/Audio Failure/Radio Reception (SI M65 09 16)
- FOOTWELL Module: Limited Warranty Extension To 8 Years/125,000 Miles (M01 06 16)
- BLUETOOTH Connection Failures (SI M84 01 14)
- New Programming Feature: Exclusion Of Infotainment Control Units From Programming (M09 01 15)
- CAS Module Fails Programming With COAPI Error 2082 (M61 05 15)
- Enabling Code Information (M09 02 11)
- Intermittent Humming Or Buzzing Noise From Speedometer (M62 01 13)
- Audio And Battery Failures Caused By Aftermarket USB Adapter Cable (M65 02 12)
- Programming Version Vehicle Data Status (M09 04 07)
- Loading/Activation Of Enabling Codes With ISTA/P (M09 01 11)
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- AISIN Automatic TRANSMISISON: Right Side Output Shaft Seal Replacement (SI M24 01 18)
- Mini Operating Fluids (SI M00 02 02)
- Service Action: Retrofit John Cooper Works Steering Wheel Gearshift Paddles (M32 02 13)
- Retrofit Steering Wheel With Paddle Shifters (M32 01 12)
- R55, R56, R57, R60 With F21 Transmission - Warning Lamp Illuminated With FC A0B6 (M24 01 08)
- Auxiliary Emission Control Systems
- Intermittent Poor Throttle Response At High Ambient Temperatures (M12 09 15)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Diagnosing Stored Fault Codes To Help Avoid Repeat Repair Visits (M07 01 15)
- N16: Fault 274D Mixture Adaptation Is Stored In The DME (M12 01 14)
- VACUTEC Leak Finder (M04 01 14)
- N16 Engine: FC 2D9B Knock Sensor, Signal Is Stored In The DME (M12 01 13)
- Enabling Code Information (M09 02 11)
- N14 JCW Or N16: Engine Crank, No Start And/Or Engine Coolant Temperature Sensor Faults (M11 04 12)
- Service Engine Soon Lamp Illuminated While Vehicle Is In Transportation Mode (M12 05 12)
- N16 Service Engine Soon Lamp Illuminated: DME FC 2D9B Knock Sensor Signal (M12 04 12)
- Service Engine Soon Lamp Or Check Fuel Cap Is Illuminated (M12 03 11)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- Body Interior
- USB Cable: Battery Discharge/Audio Failure/Radio Reception (SI M65 09 16)
- FOOTWELL Module: Limited Warranty Extension To 8 Years/125,000 Miles (M01 06 16)
- New Programming Feature: Exclusion Of Infotainment Control Units From Programming (M09 01 15)
- CAS Module Fails Programming With COAPI Error 2082 (M61 05 15)
- Enabling Code Information (M09 02 11)
- Service Action: Program Convertible Top Module (CVM) (M54 01 12)
- Brakes Control Systems
- Diagnosing Stored Fault Codes To Help Avoid Repeat Repair Visits (M07 01 15)
- Erroneous "Service Due" Message Although Brake Lining Thickness Is Above Minimum Specification (M34 01 13)
- Enabling Code Information (M09 02 11)
- Abs/DSC Control During Light Braking (M34 01 12)
- Magnetic Test Card For Wheel Speed Sensors (M04 01 12)
- Charging Systems
- Clutch
- Communication Devices
- USB Cable: Battery Discharge/Audio Failure/Radio Reception (SI M65 09 16)
- USB Device Is Not Detected By Champ2 Head Unit (SI M65 10 16)
- BLUETOOTH Connection Failures (SI M84 01 14)
- New Programming Feature: Exclusion Of Infotainment Control Units From Programming (M09 01 15)
- IPHONE And IOS 8.X Information (SI M84 01 15)
- Incorrect Customer Relations Telephone Number Is Saved In The Vehicle (SI M84 02 13)
- Telephone: PHONEBOOK Does Not Transfer To The Vehicle (SI M84 01 13)
- Basic SVS: Voice Recognition Inoperative After Programming (SI M65 03 13)
- Audio And Battery Failures Caused By Aftermarket USB Adapter Cable (M65 02 12)
- Cooling System (Mechanical)
- N14, N16 Thermostat Housing With Thermostat: Limited Warranty Extension To 10 Years/120,000 Miles (SI M01 05 17)
- Service Action: Retrofit Of Engine Coolant Temperature Sensor (SI M17 02 13)
- Surface Cracks On The Water Pump Drive Pulley (M11 08 15)
- Mini Operating Fluids (SI M00 02 02)
- Engine Cranks, No Start And/Or Engine Coolant Temperature Faults (M17 10 12)
- Whistling Noise From The Water Pump Area (M11 03 09)
- Service Action: Replace The Coolant Pump (M11 01 13)
- Service Action: Retrofit Of The Engine Coolant Temperature Sensor (M17 06 12)
- N14 JCW Or N16: Engine Crank, No Start And/Or Engine Coolant Temperature Sensor Faults (M11 04 12)
- N16 Service Engine Soon Lamp Illuminated: DME FC 2D9B Knock Sensor Signal (M12 04 12)
- Vacuum Charger For Engine Cooling System (M04 07 11)
- Hose Pinch Pliers (M04 04 11)
- Differentials & Drive Axles
- Engine Control Systems
- Service Action: Retrofit Of Engine Coolant Temperature Sensor (SI M17 02 13)
- Engine Misfire Due To Failed Ignition Coil (M12 01 15)
- Intermittent Poor Throttle Response At High Ambient Temperatures (M12 09 15)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Diagnosing Stored Fault Codes To Help Avoid Repeat Repair Visits (M07 01 15)
- Engine Cranks, No Start And/Or Engine Coolant Temperature Faults (M17 10 12)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- N16: Fault 274D Mixture Adaptation Is Stored In The DME (M12 01 14)
- VACUTEC Leak Finder (M04 01 14)
- N16 Engine: FC 2D9B Knock Sensor, Signal Is Stored In The DME (M12 01 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- Change In Thermostat Electrical Connector On Replacement Engine Harness (M17 04 12)
- Service Action: Retrofit Of The Engine Coolant Temperature Sensor (M17 06 12)
- Service Engine Soon Lamp Illuminated While Vehicle Is In Transportation Mode (M12 05 12)
- Programming Version Vehicle Data Status (M09 04 07)
- N16 Service Engine Soon Lamp Illuminated: DME FC 2D9B Knock Sensor Signal (M12 04 12)
- Loading/Activation Of Enabling Codes With ISTA/P (M09 01 11)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Entertainment Systems
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- USB Cable: Battery Discharge/Audio Failure/Radio Reception (SI M65 09 16)
- USB Device Is Not Detected By Champ2 Head Unit (SI M65 10 16)
- New Programming Feature: Exclusion Of Infotainment Control Units From Programming (M09 01 15)
- Telephone: PHONEBOOK Does Not Transfer To The Vehicle (SI M84 01 13)
- Basic SVS: Voice Recognition Inoperative After Programming (SI M65 03 13)
- Champ2: Integrated Cooling Fan Is Noisy Intermittently (M65 01 13)
- Audio And Battery Failures Caused By Aftermarket USB Adapter Cable (M65 02 12)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Fuel System
- F5X F60 B36 B46 EVAP Purge (Vent) Valve Ext Ltd WTY (ELW) 15 Years/150,000 Miles 118001, 118401, 190F08 , 191C02, 191C02 (SI M01 01 24)
- Fuel Tank Siphon Kit - Gasoline (SI M04 03 18)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- VACUTEC Leak Finder (M04 01 14)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Fuel Level Sensor Repair Procedure (M16 01 09)
- Alcohol Fuel Blends In Mini Vehicles (M13 01 06)
- Mini Fuel System Cleaner Plus (M13 05 06)
- Service Engine Soon Lamp Or Check Fuel Cap Is Illuminated (M12 03 11)
- Fuel Composition Tester (M04 05 11)
- Testing Fuel Composition (M13 05 10)
- Hose Pinch Pliers (M04 04 11)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Headlights
- HVAC Control Systems
- Identification
- Ignition System
- Infotainment
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- USB Cable: Battery Discharge/Audio Failure/Radio Reception (SI M65 09 16)
- USB Device Is Not Detected By Champ2 Head Unit (SI M65 10 16)
- Antenna Test Cables (M04 04 16)
- NAV Road Map Installation Using USB Stick (SI M65 10 15)
- Telephone: PHONEBOOK Does Not Transfer To The Vehicle (SI M84 01 13)
- Basic SVS: Voice Recognition Inoperative After Programming (SI M65 03 13)
- Champ2: Integrated Cooling Fan Is Noisy Intermittently (M65 01 13)
- Interior/Exterior Trim
- Lubrication System
- Clean Oil Service System (SI M04 01 23)
- Engine Oil Pressure Diagnosis Hints (SI M11 02 23)
- External Engine Oil Leaks And Repairs (SI M01 05 21)
- Engine Replacement And Engine Repairs (M11 04 15)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- N16 And N18 Engine: Engine Oil Leak (M11 01 12)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- N16 Engine: Oil Leak From Cylinder Head Sealing Plug (M11 04 14)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- N12, N14, N16 And N18: Engine Oil Filter Kit Information (M11 02 11)
- Mechanical Tools For The N16 And N18 Engines (M04 01 11)
- Manual Steering
- Manual Trans
- Mechanical
- Engine Replacement And Engine Repairs (SI M11 02 20)
- Engine Replacement And Engine Repairs (M11 04 15)
- Crankshaft Seal And Bed Plate Liquid Sealer (M11 11 16)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Surface Cracks On The Water Pump Drive Pulley (M11 08 15)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- N16 And N18 Engine: Engine Oil Leak (M11 01 12)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Dual Mass Flywheel: Diagnosis And Inspection (M21 01 14)
- N16 Engine: Oil Leak From Cylinder Head Sealing Plug (M11 04 14)
- Valve Guide To Valve Stem Wear Specification (M11 06 14)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- VACUTEC Leak Finder (M04 01 14)
- Whistling Noise From The Water Pump Area (M11 03 09)
- Resealing The Engine Oil Pan (M11 03 12)
- Engine Cross-Member And Supports (M04 10 11)
- N12, N14, N16 And N18: Engine Oil Filter Kit Information (M11 02 11)
- Mechanical Tools For The N16 And N18 Engines (M04 01 11)
- Mechanical - Hydraulic
- Vibration When Braking: Diagnosing And Repairing (M34 02 15)
- Brake Pad Maintenance Services: Brake Disc Resurfacing Guidelines (SI M34 04 16)
- On-Car Brake Lathe (SI M34 05 16)
- Elimination Of Brake Service Bundling On Newer Models (SI M01 08 16)
- Mini Operating Fluids (SI M00 02 02)
- Erroneous "Service Due" Message Although Brake Lining Thickness Is Above Minimum Specification (M34 01 13)
- Brake Disc And Brake Pad Service And Reference Information (M34 01 14)
- Brake Rotor Minimum Thickness (M34 01 10)
- Procedures
- Mini Dealer Self-Authorized (DSA) Goodwill And The Elite Shop Programs (SI M01 06 03)
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Mini Engine Oil (SI M11 01 21)
- Mini Alternate Transportation Measures (ATM): Amp And Rental Vehicles (SIM 01 02 21)
- The New Mini Dealer Retail Audit Approach (SI M00 02 21)
- What's New In ISPI Next 20.2 (SI M05 01 20)
- Mini Warranty Simplification Program (WSP) Diagnosis Work Time Flat Rate Concept (SI M01 04 20)
- Mini Warranty Simplification Program (WSP) Standard Variable Diagnosis Work Time (SI M01 01 20)
- QCI Claim Payment And Process Change (SI M01 01 08)
- Mini MOTORER Obsession (Reboot): Non-Repair Customer Goodwill Initiative (SI M01 09 14)
- BMW Group Technical Support And New TSARA Hotline (TRI M00 02 19)
- OC3 Seat Occupancy Mat: Limited Warranty Extension To 10 Years/120,000 Miles (SI M01 11 16)
- TIS 2.0 Launches On December 13TH (SI M10 01 18)
- IRAP Control Unit Recovery (SI M09 01 18)
- Mini Engine: Oil Repair Order Invoicing Procedure (SI M01 04 15)
- Mini Recall/Service Action Repairs Alternative Mobility Solutions (AMS) (SI M01 01 17)
- Tool Rental Program (SI M04 05 17)
- Bonnet, Boot & Wings: 39TH Edition (SI M06 03 17)
- IRAP Next (SI M09 01 16)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Mini Maintenance Program: Remote Control/Key Battery Replacement (M01 02 13)
- Rear Suspension
- Restraints Control Systems
- Schedule
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Mini Maintenance Program: Remote Control/Key Battery Replacement (M01 02 13)
- 2013 Model Year New Vehicle Preparation And Maintenance Requirements (SI M00 03 12)
- Seats
- Starter
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Approved Battery Charger/Power Supplies (M04 08 09)
- Discharged Battery: Energy Diagnosis Must Be Performed (M61 06 07)
- Transport Mode Switching Device: TMSD (M04 11 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- EXIDE Replacement Batteries (M01 09 13)
- Updated Battery Registration Procedure (M61 03 12)
- Battery Charge Condition Not Available In Energy Diagnosis (M61 01 13)
- Audio And Battery Failures Caused By Aftermarket USB Adapter Cable (M65 02 12)
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Mini Operating Fluids (SI M00 02 02)
- Wear Marks On Convertible Top (M54 04 13)
- Service Action 63 - Convertible Top Does Not Close (M54 05 13)
- Convertible Top Cannot Be Locked Or Secured When Fully Opened Or Closed (M54 03 13)
- Convertible Top Rattles When Open (M54 02 13)
- White Wear Marks On Canvas Top (M54 01 13)
- Service Action: Program Convertible Top Module (CVM) (M54 01 12)
- Suspension Control Systems
- System
- Engine Misfire Due To Failed Ignition Coil (M12 01 15)
- Intermittent Poor Throttle Response At High Ambient Temperatures (M12 09 15)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Diagnosing Stored Fault Codes To Help Avoid Repeat Repair Visits (M07 01 15)
- Engine Cranks, No Start And/Or Engine Coolant Temperature Faults (M17 10 12)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- N16: Fault 274D Mixture Adaptation Is Stored In The DME (M12 01 14)
- VACUTEC Leak Finder (M04 01 14)
- N16 Engine: FC 2D9B Knock Sensor, Signal Is Stored In The DME (M12 01 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- Change In Thermostat Electrical Connector On Replacement Engine Harness (M17 04 12)
- Service Engine Soon Lamp Illuminated While Vehicle Is In Transportation Mode (M12 05 12)
- N16 Service Engine Soon Lamp Illuminated: DME FC 2D9B Knock Sensor Signal (M12 04 12)
- Tech Tip
- Transfer Case
- Transmission Control Systems
- Wheel Alignment
- Wheels & Tire System
- Tire Pressure Control System (RDC) Tool (SI M04 01 19)
- Tire Valve Torque Wrench (SI M04 04 18)
- Stripped Locking Wheel Bolts (M04 05 16)
- New Wheel Balancing Adapter Kit (M04 02 14)
- Valve Stem Replacement With Wheel Electronics (M36 02 15)
- ATEQ VT-55 Tire Pressure Monitoring System Diagnostic Tool (M04 05 14)
- Mini Tire Center Target Satisfaction Program (M01 01 04)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.