Catalyst And Exhaust Systems: Overview: Notes

2021 Ford Transit-350 XL, 3.5L Eng VIN G, AWDSECTION Notes
WARNING: This page does not describe the selected car, but rather 26 other vehicles, including the 2020 Lincoln Navigator, 2020 Lincoln Nautilus, 2020 Lincoln MKZ, 2020 Lincoln Corsair, and 2020 Lincoln Continental. However, it is still accessible from the selected car via links, so may be relevant.

The catalytic converter and exhaust systems work together to control the release of harmful engine exhaust emissions into the atmosphere. The engine exhaust gas consists mainly of nitrogen (N), carbon dioxide (CO2 ) and water (H2 O). However, it also contains carbon monoxide (CO), nitrogen oxides (NOx ), hydrogen (H), and various unburned hydrocarbons (HCs). The major air pollutants of CO, NOx , and HCs, and their emission into the atmosphere must be controlled.

The exhaust system generally consists of an exhaust manifold, a front exhaust pipe, a universal heated oxygen sensor (HO2S), a rear exhaust pipe, a catalyst HO2S, a muffler, and an exhaust tailpipe. The catalytic converter is typically installed between the front and rear exhaust pipes. On some vehicle applications, more than one catalyst is used between the front and rear exhaust pipes. Catalytic converter efficiency is monitored by the on board diagnostic (OBD) system strategy in the PCM. For additional information on the OBD catalyst monitor, refer to the description for the CATALYST EFFICIENCY MONITORΒ .

Only 2 heated oxygen sensors are used in an exhaust stream. The universal HO2S is before the catalyst (universal HO2S11 or universal HO2S21) and used for primary fuel control while the rear HO2S is after the catalyst (HO2S12 or HO2S22) and used to monitor catalyst efficiency.

RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

  • β€’ You smell fuel, burning insulation, or see smoke.
  • β€’ Brakes feel soft, pull hard to one side, or make grinding noises.
  • β€’ The engine overheats, stalls repeatedly, or misfires under load.
  • β€’ You are missing required tools, torque specs, or safe lifting equipment.
  • β€’ You are not confident in the next step or safety outcome.