Safety Warning

DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.

SYS.OK|MANUAL.DB● LIVE

HOMESERVICE MANUALSFORD2007FUSION SEL, 2.3 Z, STANDARDREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 1009 (WIPER SYSTEM AND WASHER SYSTEM)DIAGNOSTIC TESTSWIPERS AND WASHERSSYMPTOM CHART

2007 Ford Fusion SEL, 2.3 Z, Standard

Symptom Chart

2007 Ford Fusion SEL, 2.3 Z, StandardSECTION Symptom Chart

WARNING: This page is about a different car, the 2008 Mercury Mariner and 2008 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.

Symptom Chart - Wipers and Washers

Condition	Possible Sources	Action
The wipers are inoperative - windshield	Fuse(s) Multi-function switch Circuitry Windshield wiper motor	Go to Pinpoint Test A .
The wipers are inoperative - rear window	Fuse(s) Multi-function switch Circuitry Rear window wiper motor	Go to Pinpoint Test B .
The wipers stay on continuously - windshield	Windshield wiper motor Multi-function switch Circuitry	Go to Pinpoint Test C .
The wipers stay on continuously - rear window	Rear window wiper motor Multi-function switch Circuitry	Go to Pinpoint Test D .
The high/low wiper speeds do not operate correctly - windshield	Multi-function switch Circuitry Windshield wiper motor	Go to Pinpoint Test E .
The intermittent wiper speed does not operate correctly - rear window	Multi-function switch Circuitry Rear window wiper motor	Go to Pinpoint Test F .
The intermittent wiper speed does not operate correctly - windshield	Multi-function switch Circuitry Windshield wiper motor	Go to Pinpoint Test G .
The wash and wipe function is inoperative - windshield	Windshield wiper motor	If the washer pump is inoperative, go to Pinpoint Test H . If the washer pump is operative, INSTALL a new windshield wiper motor. TEST the system for normal operation.
The wash and wipe function is inoperative - rear window	Multi-function switch Circuitry Washer pump Rear window wiper motor	If the washer pump is inoperative, go to Pinpoint Test H . If the washer pump is operative, INSTALL a new rear wiper motor. TEST the system for normal operation.
The washer pump is inoperative	Circuitry Windshield washer pump Multi-function switch Windshield wiper motor Rear window wiper motor	Go to Pinpoint Test H .
The wipers will not park at the correct position - windshield	Linkage Windshield wiper motor	If the wipers immediately stop on the windshield as soon as they are turned off, INSTALL a new windshield wiper motor.
	Pivot arm adjustment	ADJUST pivot arm, REFER to Wiper Blade and Pivot Arm Adjustment - Windshield .
The wipers will not park at the correct position - rear window	Pivot arm adjustment	ADJUST pivot arm, REFER to Wiper Blade and Pivot Arm Adjustment - Rear .
The headlamps do not illuminate when the wipers are on	Circuitry Windshield wiper motor SJB	Go to Pinpoint Test I .

RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

Shop Manual-Ready Tools Free Quote Check Quote Shield Pro

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

• You smell fuel, burning insulation, or see smoke.
• Brakes feel soft, pull hard to one side, or make grinding noises.
• The engine overheats, stalls repeatedly, or misfires under load.
• You are missing required tools, torque specs, or safe lifting equipment.
• You are not confident in the next step or safety outcome.