Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
Preliminary Checks
Most driveability problems in the Chrysler multi-point EFI system result from faulty or poor wiring, or loose and/or leaking hose connections. To avoid unnecessary component testing, a visual check should be performed before beginning trouble shooting procedures to help spot these common faults. A preliminary visual check should nclude:
- Air ducts to air cleaner, from the air cleaner to turbocharger and from turbocharger to throttle body.
- All component electrical connections must be clean, tight and unbroken.
Check vacuum lines for secure, leak-free connections in these reas:
- Throttle body.
- EGR and purge solenoids (located on a common bracket at right rear corner of engine compartment).
- Vapor canister.
- PCV valve to turbocharger vacuum port.
- Back pressure transducer.
- MAP sensor.
Ensure that the following electrical connectors are securely ttached:
- 21-way connectors (2) at logic module (Blue connector to Blue socket, Red connector to Red socket).
- 3-way connector at MAP sensor.
- 3-way and 1-way connectors at ASD relay.
- 12-way and 10-way connectors at power module.
- 3-way connector at EGR and purge solenoids.
- 2-way connector at speed sensor (located in line with speedometer cable).
- 2-way connector at charge temperature sensor.
- 6-way connector at throttle body.
- 2-way connector at each fuel injector.
- O2 sensor connector.
- 2-way connector at coolant temperature sensor.
- 3-way connector at distributor.
- 1-way connector at knock sensor (located at rear of valve cover).
- Harness ground eyelet mounting to intake manifold.
NO RELATED
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- β’ You smell fuel, burning insulation, or see smoke.
- β’ Brakes feel soft, pull hard to one side, or make grinding noises.
- β’ The engine overheats, stalls repeatedly, or misfires under load.
- β’ You are missing required tools, torque specs, or safe lifting equipment.
- β’ You are not confident in the next step or safety outcome.