SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2008HHR LT, 2.4 P, AUTOMATICREPAIR AND DIAGNOSIS (SINGLE PAGE)BODY & FRAMEEXTERIOR/INTERIOR TRIMINTERIOR TRIM AND PANELINGREPAIR INSTRUCTIONSFRONT SIDE DOOR TRIM PANEL REPLACEMENT
2008 Chevrolet HHR LT, 2.4 P, Automatic

Front Side Door Trim Panel Replacement

2008 Chevrolet HHR LT, 2.4 P, AutomaticSECTION Front Side Door Trim Panel Replacement
Fig 1: Front Side Door Trim Panel Replacement
GM1606577Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Front Side Door Armrest Pull Cup Liner
2 Front Side Door Armrest Pull Cup Screws (Qty: 2)
NOTE: Refer to Fastener Notice .

Tighten:  3 N.m (25 lb in)
3 Front Side Door Inside Handle Cover
4 Front Side Door Inside Handle Screw

Tighten:  3 N.m (25 lb in)
5 Front Side Door Trim Panel
Tip: 
  1. Remove Push-in retainer on trailing/back edge of the door trim panel.
  2. Use a J 38778  Door Trim Pad Clip Remover to aid in the removal of the side door trim panel.
  3. Disconnect the inside door handle linkage.
6 Door Trim Panel Retainer Clips (Qty: 9)
Tip:  Disconnect the electrical connectors.
RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

Shop Manual-Ready ToolsFree Quote CheckQuote Shield Pro

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

  • • You smell fuel, burning insulation, or see smoke.
  • • Brakes feel soft, pull hard to one side, or make grinding noises.
  • • The engine overheats, stalls repeatedly, or misfires under load.
  • • You are missing required tools, torque specs, or safe lifting equipment.
  • • You are not confident in the next step or safety outcome.