Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2008CHEVY EXPRESS G2500, VAN CARGO, 6.6 6REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 606 (STEERING WHEEL AND STEERING COLUMN)
2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6
Section 606 (Steering Wheel And Steering Column)
2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6SECTION Section 606 (Steering Wheel And Steering Column)
WARNING: This page is about a different car, the 2003 GMC Sierra, 2003 GMC Cab & Chassis Sierra, 2003 Chevrolet Silverado, and 2003 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Intermediate Steering Shaft Replacement - Upper
- Intermediate Steering Shaft Replacement - Lower
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Ignition Switch Replacement
- Ignition Lock Cylinder Replacement
- Ignition Lock Cylinder Case Replacement (Floor Shift)
- Ignition Lock Cylinder Case Replacement (Column Shift)
- Multifunction, Turn Signal Switch Replacement
- Shift Lever Replacement (With Tow/Haul Switch)
- Shift Lever Replacement (Without Tow/Haul Switch)
- Linear Shift Assembly Replacement
- Tilt Lever Replacement
- Horn Switch Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Housing Replacement (Tilt)
- Steering Column Tilt Head Housing Replacement (Standard)
- Turn Signal Cancel Cam and Upper Bearing Thrust Washer
- Steering Column Replacement
- Steering Column Seal Replacement
- Lower Bearing and Steering Column Jacket Replacement (Column Shift Lean Shaft)
- Lower Bearing and Steering Column Jacket Replacement (Floor Shift Lean Shaft)
- Lower Bearing and Steering Column Jacket Replacement (Column Shift Standard)
- Lower Bearing and Steering Column Jacket Replacement (Floor Shift Standard)
- Steering Wheel Position Sensor Replacement
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.