SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2008CHEVY EXPRESS G2500, VAN CARGO, 6.6 6REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 1963 (WIPER SYSTEM & WASHER SYSTEM)REPAIR INSTRUCTIONSWINDSHIELD WASHER PUMP REPLACEMENT
2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6

Windshield Washer Pump Replacement

2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6SECTION Windshield Washer Pump Replacement
WARNING: This page is about a different car, the 2009 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Windshield Washer Pump
GM1878196Courtesy of GENERAL MOTORS CORP.
Callout Component Name
Preliminary Procedure: 
Remove the left front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement .
1 Windshield Washer Pump Front

Procedure

  1. Drain the windshield washer solvent into a suitable clean container.
  2. Disconnect the electrical connector to the front washer pump.
  3. Disconnect the washer pump hose at the pump.
  4. Using 2 flat-bladed tools under the base of the washer pump, pry upward in order to release the pump from the washer pump grommet.
  5. Discard the washer pump and grommet.

Tip: 

Use full strength washer solvent on the new grommet in order to aid in the installation of the new front windshield washer container pump.
RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

Shop Manual-Ready ToolsFree Quote CheckQuote Shield Pro

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

  • • You smell fuel, burning insulation, or see smoke.
  • • Brakes feel soft, pull hard to one side, or make grinding noises.
  • • The engine overheats, stalls repeatedly, or misfires under load.
  • • You are missing required tools, torque specs, or safe lifting equipment.
  • • You are not confident in the next step or safety outcome.