SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2008CHEVY EXPRESS G2500, VAN CARGO, 6.6 6REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 1210 (WIRING SYSTEMS AND POWER MANAGEMENT - COMPONENT VIEWS)FRONT OF VEHICLE/ENGINE COMPARTMENT COMPONENT VIEWS
2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6

Front of Vehicle/Engine Compartment Component Views

2008 Chevrolet Chevy Express G2500, Van Cargo, 6.6 6SECTION Front of Vehicle/Engine Compartment Component Views
WARNING: This page is about a different car, the 2008 GMC Sierra, 2008 GMC Cab & Chassis Sierra, 2008 Chevrolet Silverado, and 2008 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Front of the Vehicle Components (10 Series)
GM1860643Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Hood
2 Inflatable Restraint Front Sensor - Left
3 Inflatable Restraint Front Sensor - Right
Fig 2: Front of the Vehicle Components (except 10 Series)
GM1922981Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Lower Radiator Support
2 Inflatable Restraint Front End Sensor
Fig 3: Front of the Vehicle Components (X88)
GM1854075Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Park/Turn Signal Lamp - Upper Right
2 Headlmap - Right Low Beam
3 Headlmap - Left Low Beam
4 Park/Turn Signal Lamp - Upper Left
5 Park/Turn Signal Lamp - Lower Left
6 Headlamp - Left High Beam
7 Fog Lamp - Left Front (T96)
8 Fog Lamp - Right Front (T96)
9 Headlamp - Right High Beam
10 Park/Turn Signal Lamp - Lower Right
Fig 4: Front of the Vehicle Components (Z88)
GM1854076Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Headlamp - Right Low Beam
2 Park/Turn Signal Lamp - Upper Right
3 Park/Turn Signal Lamp - Upper Left
4 Headlamp - Left Low Beam
5 Marker Lamp - Left Front
6 Headlamp - Left High Beam
7 Park/Turn Signal Lamp - Lower Left
8 Fog Lamp - Left Front (T96)
9 Fog Lamp - Right Front (T96)
10 Park/Turn Signal Lamp - Lower Right
11 Headlamp - Right High Beam
12 Marker Lamp - Right Front
Fig 5: Behind the Grill Components - 1 of 3
GM1858048Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Upper Tie Bar
2 Hood Ajar Switch (AP3/AP8)
3 Ambient Air Temperature Sensor - ISRVM
Fig 6: Behind the Grill Components - 2 of 3
GM1750395Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Horn - Right (7Z1/YE9)
2 Radiator Core Support
3 Horn - Left
Fig 7: Behind the Grill Components - 3 of 3
GM1822407Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Radiator Core Support
2 Ambient Air Temperature Sensor (DF5)
3 Ambient Air Temperature Sensor - HVAC (CJ2)
Fig 8: Front of the Engine Compartment Components (Gas -LY6)
GM1539137Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Engine Cooling Fan - Left
2 Engine Cooling Fan - Right
3 Forward Lamp Harness
Fig 9: Front of the Engine Compartment Components (Diesel)
GM1870635Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Engine
2 Front Fascia
3 A/C Low Pressure Switch (C67/CJ2)
4 Surge Tank
5 Engine Coolant Level Switch
Fig 10: Left Rear ot the Engine Compartment Components
GM1714226Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Windshield Wiper Motor
2 Power Brake Booster (JL4)
3 Windshield Washer Solvent Heater (XA7)
4 Fuse Block - Underhood
5 Engine Control Module (ECM)
6 Transmission Control Module (TCM) (M30/M70/MW7)
7 Brake Booster Vacuum Sensor (JL4)/Brake Master Cylinder Pressure Sensor (JL1)
8 Brake Fluid Level Switch
Fig 11: Right Rear of the Engine Compartment (4.8L/5.3L/6.0L/6.2L)
GM1714221Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Battery - Right
2 A/C Low Pressure Switch (C67/CJ2)
3 A/C Compressor Clutch (C67/CJ2)
4 A/C Refrigerant Pressure Sensor (C67/CJ2)
5 Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor
Fig 12: Rear of the Engine Compartment Components
GM1858046Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Battery - Right
2 Windshield Wiper Motor
3 Windshield Washer Solvent Heater (XA7)
4 Fuse Block - Underhood
5 Battery - Left (Diesel/6A6/T92)
6 Washer Washer Fluid Level Switch
7 Windshield Washer Fluid Pump
8 Air Cleaner Box
Fig 13: Rear of the Engine Compartment Components (4.3L)
GM1888657Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Battery Current Sensor (except MEX)
2 Mega Fuse
3 A/C Low Pressure Switch (C67/CJ2)
4 Fuse Block - Underhood
5 Engine Control Module (ECM)
6 A/C Refrigerant Pressure Sensor (C67/CJ2)
7 Mass Airflow (MAF)/Intake Air Temperature (IAT) Sensor
8 Battery - Right
Fig 14: Rear of the Engine Compartment Components (Diesel)
GM1870628Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Battery - Right
2 Fuse Holder - Underhood
3 X127
4 X108
5 X107
6 X123 (PTO)
7 Fuse Block - Underhood
8 X109
9 Battery - Left
10 Engine Control Module (ECM)
11 Transmission Control Module (TCM) (MX7)
Fig 15: Rear of the Engine Compartment Components (TP2)
GM1934393Courtesy of GENERAL MOTORS CORP.
Callout Component Name
1 Fuse Holder - Underhood
2 Run Relay
3 Auxiliary Battery Harness
4 Auxiliary Battery Relay
5 X122
RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

Shop Manual-Ready ToolsFree Quote CheckQuote Shield Pro

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

  • • You smell fuel, burning insulation, or see smoke.
  • • Brakes feel soft, pull hard to one side, or make grinding noises.
  • • The engine overheats, stalls repeatedly, or misfires under load.
  • • You are missing required tools, torque specs, or safe lifting equipment.
  • • You are not confident in the next step or safety outcome.