Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2006COBALT SS, 4D SEDAN, STANDARDREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 356 (ENGINE MECHANICAL - 3.9L)COMPONENT LOCATORDISASSEMBLED VIEWS
2006 Chevrolet Cobalt SS, 4D Sedan, Standard
Disassembled Views
2006 Chevrolet Cobalt SS, 4D Sedan, StandardSECTION Disassembled Views
WARNING: This page is about a different car, the 2006 Chevrolet Monte Carlo and 2006 Chevrolet Impala. However, it is still accessible from the selected car via links, so may be relevant.
| Callout | Component Name |
|---|---|
| 317 | Coolant Crossover Pipe |
| 318 | Coolant Crossover Pipe Bolt - Small |
| 319 | Coolant Crossover Pipe Bolt - Large |
| 320 | Engine Lift Bracket - Front |
| 321 | Engine Lift Bracket Bolt - Small |
| 322 | Engine Lift Bracket Bolt - Large |
| 323 | Coolant Fill Adapter Seal |
| 324 | Coolant Fill Adapter |
| 325 | Coolant Fill Cap Seal - Large |
| 326 | Coolant Fill Cap |
| 327 | Coolant Crossover Pipe Gasket - Right |
| 328 | Coolant Crossover Pipe Gasket - Left |
| 332 | Idler Pulley - Upper |
| 333 | Idler Pulley - Lower |
| 334 | Idler Pulley Bolt - Upper |
| 335 | Idler Pulley Bolt - Lower |
| 336 | Coolant Fill Cap Seal - Small |
| 340 | Coolant Fill Adapter Bolt |
| 341 | Idler Pulley |
| 342 | Idler Pulley Bolt |
| 500 | Upper Intake Manifold |
| 501 | Upper Intake Manifold Stud |
| 502 | Upper Intake Manifold Bolt - Large |
| 503 | Upper Intake Manifold Bolt - Small |
| 504 | MAP Sensor Bracket |
| 505 | MAP Sensor |
| 506 | MAP Sensor Seal |
| 507 | EVAP Purge Valve Seal |
| 508 | EVAP Purge Valve |
| 509 | EVAP Purge Valve Bolt |
| 510 | Throttle Body Seal |
| 511 | Throttle Body |
| 512 | Throttle Body Bolt |
| 513 | Upper Intake Manifold Gasket |
| 514 | Throttle Body Stud |
| 515 | Throttle Body Nut |
| 516 | Intake Manifold Tuning Valve |
| 525 | Valve Rocker Cover Seal |
| 526 | Valve Rocker Cover - LH |
| 529 | PCV Tube - Fresh Air |
| 530 | Oil Fill Cap |
| 531 | Oil Fill Cap Seal |
| 532 | Oil Fill Tube |
| 533 | PCV Tube - Fool Air |
| 534 | Oil Fill Tube Seal |
| 550 | Intake Manifold Tuning Valve Bolt |
| 555 | Intake Manifold Tuning Valve Seal |
| 700 | Ignition Coil Assembly |
| 701 | Ignition Coil Assembly Stud |
| 702 | Ignition Coil Assembly Nut |
| 703 | Ignition Coil Assembly Bolt |
| Callout | Component Name |
|---|---|
| 200 | Cylinder Head |
| 201 | Valve Seal - Exhaust |
| 202 | Valve Spring |
| 203 | Valve Spring Cap |
| 204 | Valve Stem Key |
| 205 | Valve Pushrod - Exhaust |
| 206 | Valve Rocker Arm |
| 207 | Valve Rocker Arm Bolt |
| 208 | Cylinder Head Bolt |
| 209 | Valve Seal - Intake |
| 210 | Engine Mount Strut Bracket Bolt |
| 212 | Spark Plug |
| 213 | Exhaust Valve |
| 214 | Intake Valve |
| 215 | Cylinder Head Gasket - RH |
| 216 | Cylinder Head Locating Pin |
| 218 | Engine Mount Strut and A/C Compressor Bracket Bolt - Long |
| 219 | Engine Mount Strut Bracket |
| 238 | Cylinder Head Expansion Plug |
| 239 | Valve Guide |
| 240 | Valve Seat - Exhaust |
| 241 | Valve Seat - Intake |
| 242 | Valve Pushrod - Intake |
| 246 | Engine Mount Strut and A/C Compressor Bracket Bolt - Short |
| 247 | Engine Mount Strut and A/C Compressor Bracket |
| 248 | Cylinder Head Gasket - LH |
| 517 | Fuel Rail Bolt |
| 518 | Fuel Rail |
| 519 | Fuel Injector Seal |
| 520 | Lower Intake Manifold Bolt - Long |
| 521 | Lower Intake Manifold |
| 522 | Lower Intake Manifold Bolt - Short |
| 523 | Lower Intake Manifold Gasket |
| 524 | Lower Intake Manifold Seal |
| 527 | Valve Rocker Cover Bolt |
| 528 | Valve Rocker Cover Bolt Grommet |
| 535 | Valve Rocker Cover - RH |
| 536 | Fuel Schrader Valve |
| 537 | Fuel Service Port Cap Seal |
| 547 | Fuel Service Port Cap |
| 548 | Fuel Injector Retaining Clip |
| 549 | Fuel Injector |
| 558 | Lower Intake Manifold Locating Pin |
| 600 | Exhaust Manifold - Left |
| 601 | Exhaust Manifold - Right |
| 602 | Exhaust Manifold Heat Shield - Right - Upper |
| 603 | Exhaust Manifold Heat Shield Bolt |
| 604 | Exhaust Manifold Gasket - LH |
| 605 | Exhaust Manifold Bolt |
| 606 | Heated Oxygen Sensor |
| 607 | Exhaust Manifold Gasket - RH |
| 608 | Exhaust Manifold Heat Shield - Left - Upper |
| 609 | Exhaust Crossover Stud |
| 612 | Exhaust Crossover |
| 613 | Exhaust Crossover Nut |
| 614 | Exhaust Crossover Heat Shield |
| 615 | Exhaust Crossover Heat Shield Bolt |
| 704 | Spark Plug Wire Harness - Front |
| 705 | Spark Plug Wire Support Clip |
| 715 | Spark Plug Wire Harness - Rear |
| 716 | Coolant Temperature Sensor |
| 717 | Wiring Harness |
| 719 | Wiring Connector Bracket |
| 720 | Wiring Connector Bracket Bolt |
| Callout | Component Name |
|---|---|
| 100 | Engine Block |
| 101 | Camshaft Rear Bearing Hole Plug |
| 102 | Engine Block Oil Gallery Plug |
| 104 | Transmission Locating Pin |
| 105 | Engine Block Coolant Drain Hole Plug |
| 107 | Engine Block Oil Gallery Plug - Front |
| 108 | Engine Block Heater Plug |
| 109 | Engine Block Heater |
| 111 | Crankshaft Rear Oil Seal |
| 126 | Connecting Rod Bearing Cap Bolt |
| 127 | Connecting Rod Bearing Cap |
| 128 | Connecting Rod Bearing |
| 129 | Connecting Rod |
| 130 | Piston Pin |
| 131 | Piston |
| 132 | Piston Ring - Oil Control |
| 133 | Piston Ring - Compression - Lower |
| 134 | Piston Ring - Compression - Upper |
| 139 | Piston Pin Retainer Clip |
| 141 | A/C Compressor Bracket |
| 142 | A/C Compressor Bracket Bolt |
| 211 | Camshaft Position Actuator Filter |
| 217 | Timing Chain |
| 220 | Camshaft Thrust Plate Bolt |
| 221 | Camshaft Thrust Plate |
| 222 | Camshaft |
| 223 | Camshaft Bearing - 2 and 3 |
| 224 | Camshaft Bearing - 4 |
| 225 | Timing Chain Tensioner |
| 226 | Timing Chain Tensioner Bolt |
| 227 | Crankshaft Sprocket |
| 235 | Valve Lifter Guide Bolt |
| 236 | Valve Lifter Guide |
| 237 | Valve Lifter |
| 243 | Camshaft Bearing - 1 |
| 244 | Camshaft Position Actuator |
| 245 | Camshaft Position Actuator Bolt |
| 300 | Water Pump |
| 301 | Water Pump Gasket |
| 302 | Water Pump Bolt |
| 303 | Water Pump Pulley |
| 304 | Water Pump Pulley Bolt |
| 305 | Heater Inlet and Outlet Pipe Assembly - to Coolant Crossover |
| 306 | Heater Inlet and Outlet Pipe Assembly Bolt - to Coolant Crossover |
| 307 | Heater Inlet and Outlet Pipe Assembly Seal |
| 308 | Heater Inlet and Outlet Pipe Assembly Bolt - to Cylinder Head |
| 309 | Heater Inlet and Outlet Pipe Assembly Hose Clamp |
| 310 | Heater Inlet and Outlet Pipe Assembly Hose - Small |
| 311 | Heater Inlet and Outlet Pipe Assembly Hose - Large |
| 312 | Thermostat |
| 313 | Thermostat Seal |
| 314 | Thermostat Housing |
| 315 | Thermostat Housing Bolt |
| 316 | Thermostat Housing Stud |
| 329 | Thermal Bypass Hose |
| 330 | Thermal Bypass Hose - W/O Oil Cooler |
| 331 | Thermal Bypass Hose Clamp |
| 337 | Thermal Bypass Hose - W/Oil Cooler |
| 338 | Heater Inlet and Outlet Pipe Assembly |
| 339 | Heater Inlet and Outlet Pipe Assembly Nut |
| 410 | Oil Pump Drive Bolt |
| 411 | Oil Filter Adapter Stud |
| 412 | Oil Pump Drive |
| 418 | Oil Filter Bypass Valve |
| 419 | Oil Filter Adapter |
| 420 | Oil Filter Adapter Bolt - Small |
| 421 | Oil Filter |
| 422 | Oil Filter Adapter Gasket |
| 423 | Piston Oil Nozzle |
| 424 | Piston Oil Nozzle Bolt |
| 425 | Oil Filter Fitting |
| 440 | Oil Pump Drive Seal |
| 445 | Oil Filter Gasket |
| 446 | Oil Cooler Connector |
| 447 | Oil Cooler Assembly |
| 448 | Oil Cooler Assembly Seal |
| 449 | Oil Cooler Hose - Inlet |
| 450 | Oil Cooler Fitting |
| 451 | Oil Cooler Hose - Outlet |
| 452 | Oil Cooler Hose Clamp |
| 538 | Engine Front Cover |
| 539 | Engine Front Cover Gasket |
| 540 | Engine Front Cover Bolt - Small |
| 541 | Engine Front Cover Bolt - Large |
| 542 | Crankshaft Front Oil Seal |
| 543 | Crankshaft Balancer |
| 544 | Crankshaft Balancer Bolt |
| 545 | Belt Tensioner |
| 546 | Engine Front Cover Locating Pin |
| 551 | Belt Tensioner Bolt |
| 552 | Camshaft Position Actuator Magnet Bolt |
| 553 | Camshaft Position Actuator Magnet |
| 554 | Camshaft Position Actuator Magnet Seal |
| 706 | Camshaft Sensor Bolt |
| 707 | Camshaft Sensor |
| 708 | Camshaft Sensor Seal |
| 709 | Engine Oil Pressure Sensor |
| 710 | Knock Sensor |
| 711 | Knock Sensor Bolt |
| 712 | Crankshaft Position Sensor Stud |
| 713 | Crankshaft Position Sensor |
| 714 | Crankshaft Position Sensor Seal |
| Callout | Component Name |
|---|---|
| 103 | Clutch Pilot Bearing |
| 110 | Flywheel - Manual |
| 112 | Flywheel - Automatic |
| 113 | Crankshaft Lower Bearing - 3 |
| 114 | Flywheel Bolt |
| 115 | Crankshaft Upper Bearing - 1 |
| 116 | Crankshaft Upper Bearing - 2 |
| 117 | Crankshaft Upper Bearing - 3 |
| 118 | Crankshaft |
| 119 | Crankshaft Balancer Key |
| 120 | Crankshaft Lower Bearing - 2 |
| 121 | Crankshaft Lower Bearing - 1 |
| 122 | Crankshaft Bearing Cap - 1 |
| 123 | Crankshaft Bearing Cap Stud |
| 124 | Crankshaft Bearing Cap - 4 |
| 125 | Crankshaft Bearing Cap Bolt |
| 135 | Crankshaft Lower Bearing - 4 |
| 136 | Crankshaft Bearing Cap - 2 and 3 |
| 137 | Clutch Pressure Plate |
| 138 | Clutch Pressure Plate Bolt |
| 218 | Crankshaft Upper Bearing - 4 |
| 400 | Oil Pan |
| 401 | Oil Pan Gasket |
| 402 | Oil Pan Bolt - to Engine Block |
| 403 | Oil Pan Drain Plug |
| 404 | Crankshaft Oil Deflector Nut |
| 405 | Crankshaft Oil Deflector |
| 406 | Oil Pump Locating Pin |
| 407 | Oil Pump Shaft |
| 408 | Oil Pump |
| 409 | Oil Pump Bolt |
| 413 | Oil Level Indicator Tube |
| 414 | Oil Level Indicator Tube Bolt |
| 415 | Oil Level Indicator |
| 416 | Oil Pan Drain Plug Seal |
| 417 | Oil Level Indicator Seal |
| 426 | Oil Pan Bolt - Side of Pan |
| 427 | Oil Pump Screen |
| 428 | Oil Pump Plug |
| 429 | Oil Pump Valve |
| 430 | Oil Pump Spring |
| 431 | Oil Pump Cover |
| 432 | Oil Pump Cover Bolt |
| 433 | Oil Pump Pin |
| 434 | Oil Pressure Relief Valve Bore Plug |
| 435 | Oil Pump Driven Gear |
| 436 | Oil Pump Driven Shaft |
| 437 | Oil Pump Drive Gear |
| 438 | Oil Pump Drive Shaft |
| 439 | Oil Pump Housing |
| 441 | Oil Pan Support Bracket - LH |
| 442 | Oil Pan Support Bracket Bolt - LH |
| 443 | Oil Pan Support Bracket - RH |
| 444 | Oil Pan Support Bracket Bolt - RH |
| 721 | Engine Oil Level Indicator Switch Bolt |
| 722 | Engine Oil Level Indicator Switch Clip |
| 723 | Engine Oil Level Indicator Switch |
| 724 | Engine Oil Level Indicator Seal |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.