Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2006CHEVY EXPRESS G2500, VAN CARGO, 6.6 2REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 28 (ENGINE CONTROL SYSTEM - SELF-DIAGNOSTICS)DRIVE CYCLESINSPECTION/MAINTENANCE SYSTEM DTCSDESCRIPTION
2006 Chevrolet Chevy Express G2500, Van Cargo, 6.6 2
Inspection/Maintenance System DTCS: Description
2006 Chevrolet Chevy Express G2500, Van Cargo, 6.6 2SECTION Description
WARNING: This page is about a different car, the 2003 Pontiac Vibe. However, it is still accessible from the selected car via links, so may be relevant.
The following DTCs are required to set system status to YES:
Catalyst System
- P0420 - Catalyst System Low Efficiency
EVAP System
- P0440 - EVAP System
- P0441- EVAP System No Flow During Purge
- P0442 - EVAP System Small Leak Detected
- P0446 - EVAP System Vent System Performance
Oxygen Sensor System
- P0130 - HO2S 1 Circuit
- P0133 - HO2S 1 Slow Response
Oxygen Sensor Heater System
- P0135 Or P0141- HO2S 1 Heater Performance
Diagnose affected DTCs. See DIAGNOSTIC TROUBLE CODE DEFINITIONS .
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.