Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2002S10 PICKUP 2D PICKUP, 2.2 5, STANDARDREPAIR AND DIAGNOSIS (SINGLE PAGE)ELECTRICALINSTRUMENT PANEL, GAUGES & CONSOLE
2002 Chevrolet S10 Pickup 2D Pickup, 2.2 5, Standard
Instrument Panel, Gauges & Console
2002 Chevrolet S10 Pickup 2D Pickup, 2.2 5, StandardSECTION Instrument Panel, Gauges & Console
- Specifications
- Schematic & Routing Diagrams
- Component Locator
- Diagnostic Information & Procedures
- Diagnostic Starting Point - Instrument Panel, Gages & Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic System Check - Driver Information Systems
- Diagnostic System Check - Audible Warnings
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B1367: Ignition 0 Voltage Circuit Is Less Than 75 Percent Of Battery Voltage
- DTC B2961: Ignition 1 Input Is Active
- DTC P0461: No Change In Fuel Level Over Distance
- DTC P0462: Fuel Level Signal Low
- DTC P0463: Fuel Level Signal High
- DTC P0463: State Of Driver Mismatch
- DTC P0654: State Of Driver Mismatch
- Symptoms - Instrument Panel, Gages & Console
- Instrument Cluster Inoperative
- Engine Coolant Temperature Gage Inaccurate Or Inoperative
- Engine Oil Pressure Gage Inaccurate Or Inoperative
- Fuel Gage Inaccurate Or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer &/Or Odometer Inaccurate Or Inoperative
- Tachometer Inaccurate Or Inoperative
- Volt Gage Inaccurate Or Inoperative
- Low Fuel Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Temperature Display Always Reads SC
- Driver Information Center (DIC) Temperature Display Always Reads OC
- Driver Information Center (DIC) Temperature Display Inaccurate Or Inoperative
- Driver Information Center (DIC) Compass Inaccurate Or C Displayed
- Driver Information Center (DIC) Switch(Es) Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement
- IP Dimmer Switch Replacement
- Electronic Compass Calibration
- Electronic Compass Module Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Closeout/Insulator Panel Replacement - IP Lower
- Trim Panel Replacement - Knee Bolster
- Knee Bolster Replacement
- Trim Plate Replacement - IP Accessory
- Door Replacement - IP Storage Compartment Door
- Bracket Replacement - Steering Column
- Driver Information Center Replacement (Without Sunroof)
- Driver Information Center Replacement (With Sunroof)
- Driver Information Center Module Replacement
- Instrument Panel Cluster (IPC) Replacement
- Instrument Panel Cluster (IPC) Lens Replacement
- Ashtray Replacement
- IP Carrier Replacement
- Console Replacement - Front Floor - Full Length (Auto Trans)
- Console Replacement - Front Floor (Non-Full Length)
- Console Replacement - Front Floor - Full Length (Manual Trans)
- CUPHOLDER Replacement - Front Floor Console
- Description & Operation
- Special Tools & Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.