Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2002CAVALIER BASE, 4D SEDAN, 2.4 TREPAIR AND DIAGNOSIS (SINGLE PAGE)ENGINE PERFORMANCESYSTEMENGINE CONTROL SYSTEM TESTING & ENGINE COMPONENT TESTINGCOMPONENT LOCATIONSCOMPONENT LOCATIONS (3.1L VIN J - MALIBU)
2002 Chevrolet Cavalier Base, 4D Sedan, 2.4 T
Component Locations (3.1L VIN J - MALIBU)
2002 Chevrolet Cavalier Base, 4D Sedan, 2.4 TSECTION Component Locations (3.1L VIN J - MALIBU)
COMPONENT LOCATIONS (3.1L VIN J - MALIBU)
| Component | Location |
|---|---|
| A/C Compressor Clutch Relay | Left Side Of Engine Compartment, In Underhood Junction Block |
| A/C Refrigerant Pressure Sensor | Front Of Engine Compartment |
| Camshaft Position Sensor | Top Rear Of Engine |
| Cooling Fan Control Relays No. 1 & 2 | Left Side Of Engine Compartment, In Underhood Junction Block |
| Crankshaft Position Sensor (7X) | Lower Rear Of Engine |
| Crankshaft Position Sensor (24X) | Lower Rear Of Engine |
| Cruise Control Module | Right Side Of Engine Compartment |
| Data Link Connector | Under Left Side Of Instrument Panel |
| EGR Valve | Top Rear Of Engine |
| Engine Coolant Level Switch | In Right Side Of Engine Compartment |
| Engine Coolant Temperature Sensor | Top Left Of Engine |
| Engine Oil Level Switch | Rear Of Engine |
| Engine Oil Pressure Sensor | Top Left Of Engine |
| EVAP Canister Purge Solenoid | Lower Front Of Engine |
| EVAP Canister Vent Solenoid | Under Rear Of Vehicle |
| Fuel Injectors | In Intake Manifold |
| Fuel Pump Relay | Left Side Of Engine Compartment, In Underhood Junction Block |
| Fuel Tank Pressure Sensor | Under Rear Of Vehicle |
| Idle Air Control Valve | Top Left Side Of Engine |
| Ignition Control Module | Top Rear Of Engine |
| Intake Air Temperature Sensor | Top Left Side Of Engine |
| Knock Sensor | On Front Of Engine |
| Left Instrument Panel Junction Block | Left Side Of Instrument Panel |
| Manifold Absolute Pressure Sensor | Top Rear Of Engine |
| Mass Airflow Sensor | Top Left Side Of Engine |
| Post-Converter Oxygen Sensor | Rear Of Catalytic Converter |
| Powertrain Control Module | Below Left Side Of Instrument Panel, Near Steering Column |
| Pre-Converter Oxygen Sensor | Rear Of Engine, In Left Exhaust Manifold |
| Right Instrument Panel Junction Block | Right Side Of Instrument Panel |
| Throttle Position Sensor | Top Left Side Of Engine |
| Transaxle Range Switch | Left Side Of Engine |
| Underhood Junction Block | On Left Side Of Engine Compartment |
| Vehicle Speed Sensor | Rear Of Engine/Transaxle |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.