Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2002AVALANCHE 2500, RWDREPAIR AND DIAGNOSIS (SINGLE PAGE)BODY & FRAMEEXTERIOR/INTERIOR TRIMINSTRUMENT PANEL, GAUGES & CONSOLE
2002 Chevrolet Avalanche 2500, RWD
Instrument Panel, Gauges & Console
2002 Chevrolet Avalanche 2500, RWDSECTION Instrument Panel, Gauges & Console
- Specifications
- Schematic & Routing Diagrams
- Component Locator
- Diagnostic Information & Procedures
- Diagnostic Starting Point - Instrument Panel, Gauges & Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic System Check - Driver Information Systems
- Diagnostic System Check - Audible Warnings
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B0540: DIC Receives Class 2 Message Indicating Loss of Vehicle Speed
- DTC B1023: DIC Detects Switch Signal Circuit is Low
- DTC B1367: Ignition 0 Voltage Circuit Less Than 75 Percent of Battery Voltage
- DTC B2961: Ignition 1 Input is Active - Key in Ignition Switch Signal Circuit is Inactive - Signal Circuit is High
- DTC P0461: PCM Not Detecting Change in Fuel Level After Distance of 201 km (125 mi)
- DTC P0462: Detects Fuel Level Signal is Less than 3.5%
- DTC P0463: Detects Fuel Level Signal is Greater than 98%
- DTC P0608: PCM Detects Control Circuit Mismatch
- DTC P0654: PCM Detects Control Circuit Mismatch
- DTC P1431: PCM Detects No Change in Secondary Fuel Level
- DTC P1432: Fuel Level Signal 3.5% or Less
- DTC P1433: Fuel Level Signal Greater Than 98%
- Symptoms - Instrument Panel, Gauges & Console
- Instrument Cluster Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gauge Inaccurate or Inoperative
- Engine Oil Pressure Gauge Inaccurate or Inoperative
- Fuel Gauge Inaccurate or Inoperative (Dual Tank)
- Fuel Gauge Inaccurate or Inoperative (Single Tank)
- Hourmeter Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Transmission Fluid Temperature Gauge Inaccurate or Inoperative
- Volt Gauge Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- PRNDL Display Park Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Accessory Switch Replacement
- Insulator Replacement - IP
- IP Extension Replacement (Luxury)
- IP Extension Replacement (Non-Luxury)
- Knee Bolster Replacement (Non-Luxury)
- Knee Bolster Replacement (Luxury)
- Trim Panel Replacement - Instrument Panel (IP) Upper
- Bezel Replacement - IP Cluster
- Compartment Replacement - IP
- Deflector Replacement - Instrument Panel Air - Center
- Deflector Replacement - Instrument Panel Air - Left
- Deflector Replacement - Instrument Panel Air - Right Vent
- IP Assist Handle Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- 12-Volt Power Supply Replacement
- IP Trim Panel Replacement - Lower
- IP Carrier Replacement
- Door Replacement - Console Compartment
- Lock Cylinder Replace - Console Compartment Door
- Console Storage Bin Replacement (Non-Luxury)
- Console Storage Bin Replacement (Luxury)
- Clock Replacement - Console
- Console Replacement (Base Console)
- Console Replacement (Luxury Console)
- Bezel Replacement - Floor Console (Luxury)
- Bracket Replacement - Console Floor
- Power Accessory Port Replace - Front Floor Console
- Power Accessory Outlet Cover Replacement - Floor Console
- Cupholder Replacement - Front Floor Console
- Center Console End Panel Replacement
- IP Harness Replacement
- Air Distributor Duct Replacement
- Description & Operation
- Special Tools & Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.