SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CHEVY EXPRESS G3500, VAN PASSENGER EXTENDED, 6.5 FREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 852 (POWER SUN ROOF)REPAIR INSTRUCTIONSPOWER SUNROOF MODULE REPLACEMENTREMOVAL PROCEDURE
2001 Chevrolet Chevy Express G3500, Van Passenger Extended, 6.5 F

Removal Procedure

2001 Chevrolet Chevy Express G3500, Van Passenger Extended, 6.5 FSECTION Removal Procedure
WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the sunroof glass panel in the fully closed position.
  2. Remove the headliner. Refer to HEADLINER REPLACEMENT in Interior Trim.
  3. Disconnect the electrical connector from the following components:
    • The actuator
    • The express module
  4. Disconnect the rear drain hoses from the sunroof module.
  5. Disconnect the front drain hoses from the sunroof module.
  6. Have an assistant support the sunroof module before removing the bolts.
  7. Remove the sunroof module to roof bolts.
  8. Remove the sunroof module from the vehicle roof, with an assistant.
    Fig 1: Rear & Front Drain Hoses & Sunroof Module To Roof Bolts
    G01617231Courtesy of GENERAL MOTORS CORP.
RENDER: 1.0x

NO RELATED

Recommended Tools & Savings

Use the Manual With the Right Hardware

Pair factory procedures with proven DIY tools so the instructions are easier to execute.

Affiliate disclosure: We may earn a commission at no extra cost to you.

Shop Manual-Ready ToolsFree Quote CheckQuote Shield Pro

When to See a Mechanic

Stop DIY work and contact a certified mechanic immediately if any of the following apply:

  • • You smell fuel, burning insulation, or see smoke.
  • • Brakes feel soft, pull hard to one side, or make grinding noises.
  • • The engine overheats, stalls repeatedly, or misfires under load.
  • • You are missing required tools, torque specs, or safe lifting equipment.
  • • You are not confident in the next step or safety outcome.