Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CHEVY EXPRESS G3500, VAN PASSENGER EXTENDED, 6.5 FREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 438 (INSTRUMENT PANEL, GAGES, AND CONSOLE)
2001 Chevrolet Chevy Express G3500, Van Passenger Extended, 6.5 F
Section 438 (Instrument Panel, Gages, And Console)
2001 Chevrolet Chevy Express G3500, Van Passenger Extended, 6.5 FSECTION Section 438 (Instrument Panel, Gages, And Console)
WARNING: This page is about a different car, the 2003 Pontiac Aztek and 2003 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic System Check - Head Up Display
- Diagnostic System Check - Audible Warnings
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B1369: Ignition 0 Input Is Low
- DTC B2823 or B3574: Trip Odometer Reset Switch Signal Circuit Is Low
- DTC B2838, B3564, B3569 Or B3752: Reset/Mode Switch Signal Circuit Low
- DTC B2961: Ignition 0 Input Is Active
- DTC P0462: Fuel Level Signal Low
- DTC P0463: Fuel Level Signal High
- DTC P1189: Engine Oil Pressure Switch Signal Circuit Is Low
- Symptoms - Instrument Panel, Gages & Console
- Engine Coolant Temperature Gage Inaccurate Or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer And/Or Odometer Inaccurate Or Inoperative
- Tachometer Inaccurate Or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Low Engine Oil Level Indicator Always On
- Drive Information Center Temperature Display Always Reads SC
- Drive Information Center Temperature Display Always Reads OC
- Drive Information Center (DIC) Compass Inaccurate Or C Displayed
- Drive Information Center (DIC) Switch(es) Inoperative
- Outside Air Temperature Display Inaccurate or Inoperative
- Head Up Display (HUD) Inoperative
- Head Up Display (HUD) Turn Signal Inoperative (Left/Right)
- Head Up Display (HUD) Image Adjustment Inoperative
- Head Up Display (HUD) Intensity Does Not Vary
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement (Aztek)
- Ambient Air Temperature Gage Sensor Replacement (Rendezvous)
- Instrument Panel (I/P) Multifunction Switch Assembly Replacement
- Electronic Compass Calibration
- Head Up Display Switch Replacement (Rendezvous)
- Head Up Display Switch Replacement (Aztek)
- Head Up Display Module Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Knee Bolster Replacement
- Trim Plate Replacement - Instrument Panel (I/P) Accessory (Aztek)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Aztek)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Rendezvous)
- Instrument Panel (I/P) Outer Trim Cover Replacement
- Compartment Replacement - Instrument Panel (I/P)
- Striker Replacement - Instrument Panel (I/P) Compartment
- Handle Replacement - Instrument Panel (I/P) Compartment (Aztek)
- Handle Replacement - Instrument Panel (I/P) Compartment (Rendezvous)
- Lock Cylinder Replacement - Instrument Panel (I/P) Compartment
- Instrument Panel (I/P) Assist Handle Replacement
- Trim Pad Replacement - Instrument Panel (I/P) Upper (Aztek)
- Trim Pad Replacement - Instrument Panel (I/P) Upper (Rendezvous)
- Driver Information Center Switch Replacement (Rendezvous)
- Driver Information Center Switch Replacement (Aztek)
- Instrument Panel Cluster (IPC) Replacement
- Accessory Power Receptacle Replacement - 12 Volt
- Cigar Lighter Housing Replacement - Instrument Panel (I/P)
- Instrument Panel (I/P) Assembly Replacement
- Instrument Panel (I/P) Carrier Replacement
- Latch Replacement - Console Compartment Door (Rendezvous)
- Trim Plate Replacement - Console Rear (Rendezvous).
- Console Replacement - Front Floor (Aztek)
- Console Replacement - Front Floor (Rendezvous)
- Bracket Replacement - Console Floor
- Console Armrest Replacement - Front Floor (Rendezvous)
- Trim Plate Replacement - Front Floor Console (Aztek).
- Trim Plate Replacement - Front Floor Console (Rendezvous)
- Accessory Power Receptacle Replacement - Floor Console
- Description and Operation
- Special Tools & Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.