Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CHEVY EXPRESS G2500, VAN PASSENGER EXTENDED, 5.0 MREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 355 (SEAT BELT SYSTEM)DIAGNOSTIC INFORMATION AND PROCEDURESOPERATIONAL AND FUNCTIONAL CHECKSEMERGENCY LOCKING RETRACTORS
2001 Chevrolet Chevy Express G2500, Van Passenger Extended, 5.0 M
Emergency Locking Retractors
2001 Chevrolet Chevy Express G2500, Van Passenger Extended, 5.0 MSECTION Emergency Locking Retractors
WARNING: This page is about a different car, the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, and 2002 Chevrolet Chevy Express. However, it is still accessible from the selected car via links, so may be relevant.
WARNING:
Perform this test in an area clear of other vehicles or obstructions. Do not conduct this test on the open road. A large, empty parking lot is suitable. Failure to observe this precaution may result in damage to the vehicle and possible personal injury.
- Fasten the seat belts, an assistant is needed when the retractor under test is not part of the driver seat belt.
- Accelerate the vehicle slowly to 16 km/h (10 mph) and apply the brakes firmly.
- Verify that the seat belt locks when braking firmly.
- If the belt does not lock, proceed with the following steps.
- Remove the seat belt retractor assembly.
- Tilt the seat belt retractor slowly.
- Ensure that the seat belt webbing can be pulled from the retractor at an inclination of 15 degrees or less and cannot be pulled from the retractor at an inclination of 45 degrees or more.
- If the seat belt retractor does not operate as described, replace the retractor assembly. Refer to the following procedures:
- Seat Belt Replacement - Front
- Seat Belt Retractor Replacement - No. 2 Left Rear
- Seat Belt Retractor Replacement - No. 2 Right Rear
- Seat Belt Retractor Replacement - No. 3 Left Rear
- Seat Belt Retractor Replacement - No. 3 Right Rear
- Seat Belt Retractor Replacement - No. 4 Left Rear
- Seat Belt Retractor Replacement - No. 4 Right Rear
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.