Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CHEVY EXPRESS G2500, VAN CARGO EXTENDED, 5.7 R, L31/KL8REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 791 (BODY REAR END)
2001 Chevrolet Chevy Express G2500, Van Cargo Extended, 5.7 R, L31/KL8
Section 791 (Body Rear End)
2001 Chevrolet Chevy Express G2500, Van Cargo Extended, 5.7 R, L31/KL8SECTION Section 791 (Body Rear End)
WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Rear Compartment Lid Switch Replacement
- Rear Compartment Lid Ajar Switch Replacement
- Compartment Sill Plate Replacement - Rear
- Compartment Trim Panel Replacement - Rear
- Rear Wheelhouse Liner Panel Replacement
- Spoiler Replacement - Rear (Without RPO B4U Special Edition)
- Spoiler Replacement - Rear (With RPO B4U Special Edition)
- Fuel Filler Door Replacement
- Fuel Filler Pocket Replacement
- Compartment Lid Replacement - Rear
- Hinge Replacement - Rear Compartment Lid
- Strut Replacement - Rear Compartment Lid
- Lock Cylinder Replacement - Rear Compartment Lid
- Latch Replacement - Rear Compartment Lid
- Release Actuator Replacement
- Lock Striker Replacement - Rear Compartment Lid
- Wiring Harness Replacement - Rear Compartment Lid
- Pressure Relief Valve Replacement
- Weatherstrip Replacement - Rear Compartment Opening
- Description and Operation
- Special Tools and Equipment
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.