Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CHEVY EXPRESS G2500, VAN CARGO EXTENDED, 5.7 R, L31/KL8REPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 39 (ELECTRICAL COMPONENT LOCATOR)MOTORS
2001 Chevrolet Chevy Express G2500, Van Cargo Extended, 5.7 R, L31/KL8
Section 39 (Electrical Component Locator): Motors
2001 Chevrolet Chevy Express G2500, Van Cargo Extended, 5.7 R, L31/KL8SECTION Motors
WARNING: This page is about a different car, the 2002 GMC Savana and 2002 Chevrolet Chevy Express. However, it is still accessible from the selected car via links, so may be relevant.
MOTORS LOCATION
| Component | Location |
|---|---|
| Access Panel Actuators (Left Front Side) | Behind left front access panel. |
| Access Panel Actuators (Left Rear Side) | Behind left rear access panel. |
| Access Panel Actuators (Right Side) | Behind right access panel. |
| Air Temperature Actuator | Under dash, on right side of HVAC plenum. |
| Auxiliary Air Temperature Actuator | On left side of interior cabin, behind rear wheelwell. See Figure . |
| Auxiliary Blower Motor | On left side of interior cabin, behind rear wheelwell. See Figure . |
| Auxiliary Mode Actuator | On left side of interior cabin, behind rear wheelwell. See Figure . |
| Blower Motor | On right rear of engine compartment, on firewall. |
| Fuel Injection Pump (6.5L VIN F) | On top front of engine. See Figure . |
| Fuel Pump (6.5L VIN F) | On left frame rail, near center of vehicle. |
| Fuel Pump & Sender Assembly (Except 6.5L VIN F) | Under rear of vehicle, in fuel tank. |
| Ignition Timing Stepper (ITS) Motor (6.5L VIN G) | On right side of fuel injector pump. |
| Secondary Air Injection (AIR) Pump | In engine compartment, on right front frame. |
| Throttle Actuator Control (8.1L VIN G) | On right side of throttle body. |
| Windshield Washer Fluid Pump | On left front of engine compartment, at washer reservoir. |
| Windshield Wiper Motor | On left side of firewall. |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.