Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2001CAVALIER LS, 2.4 TREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 272 (STEERING WHEEL AND STEERING COLUMN)COMPONENT LOCATORSTEERING COLUMN DISASSEMBLED VIEW (TELESCOPING)
2001 Chevrolet Cavalier LS, 2.4 T
Steering Column Disassembled View (Telescoping)
2001 Chevrolet Cavalier LS, 2.4 TSECTION Steering Column Disassembled View (Telescoping)
WARNING: This page is about a different car, the 2004 Chevrolet Corvette. However, it is still accessible from the selected car via links, so may be relevant.
| Callout | Component Name |
|---|---|
| 1 | Upper Trim Cover |
| 2 | Lower Trim Cover |
| 3 | TORX® Head Screw |
| 4 | Steering Column Close Out Trim Cover |
| 5 | Flanged Prevailing Torque Nut |
| 6 | Retaining Ring |
| 7 | SIR Coil |
| 8 | Wave Washer |
| 9 | Bearing Retainer |
| 10 | Cam Orientation Plate |
| 11 | Turn Signal Cancel Cam Assembly |
| 12 | Upper Bearing Spring |
| 13 | Upper Bearing Inner Race Seat |
| 14 | Inner Race |
| 15 | Pan Head Tapping Screws |
| 16 | Steering Wheel Theft Deterrent Lock |
| 17 | Pan Head Tapping Screw |
| 18 | Windshield Wiper and Washer Switch Assembly |
| 19 | Wiper/Washer Switch Bracket |
| 20 | Steering Column Tilt Head Housing |
| 21 | Wire Harness Straps |
| 22 | Pan Head Tapping Screw |
| 23 | Turn Signal and Multifunction Switch Assembly |
| 24 | Pan Head Tapping Screw |
| 25 | Telescoping Switch Assembly |
| 26 | Pan Head Tapping Screws |
| 27 | Race and Upper Shaft Assembly |
| 28 | Centering Sphere |
| 29 | Joint Preload Spring |
| 30 | Lower Steering Shaft |
| 31 | Steering Shaft Assembly |
| 32 | Telescope Motor and Bracket Assembly |
| 33 | Connector Clip |
| 34 | Telescope Drive Motor Assembly |
| 35 | Pan Head Tapping Screw |
| 36 | Telescope Drive Bracket |
| 37 | Pan Head Tapping Screws |
| 38 | Flat Head 6-Lobed Soc Tap Screws |
| 39 | Telescope Adapter Assembly |
| 40 | Telescope Drive Ball |
| 41 | Telescope Drive Bolt |
| 42 | TORX®Head Screws |
| 43 | Telescope Motor Assembly |
| 44 | TORX® Head Screws |
| 45 | Cable Assembly |
| 46 | Support Screws |
| 47 | Tilt Bumpers |
| 48 | Pivot Pins |
| 49 | Steering Column Support Assembly |
| 50 | Tilt Spring |
| 51 | Spring Guide |
| 52 | Jacket Assembly |
| 53 | Housing Support Guide |
| 54 | Compression Spring |
| 55 | Retaining Ring |
| 56 | Shoulder Bolt |
| 57 | Jacket Hole Plug |
| 58 | Adapter and Bearing Assembly |
| 59 | Lower Spring Retainer |
| 60 | Steering Wheel Position Sensor Assembly |
| 61 | Sensor Retainer |
| 62 | Steering Shaft Seal |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.