Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET1967IMPALA BASE, 4D SEDAN, 5.3L ENG, NOT AVAILABLE TRANSREPAIR AND DIAGNOSIS (SINGLE PAGE)ENGINE PERFORMANCETUNE-UPV8 TUNE-UPMODEL IDENTIFICATIONSERIAL NUMBERNOTES
1967 Chevrolet Impala Base, 4D Sedan, 5.3L Eng, Not Available Trans
Serial Number: Notes
1967 Chevrolet Impala Base, 4D Sedan, 5.3L Eng, Not Available TransSECTION Notes
Stamped on plate attached to left front body hinge pillar. Number (example below) includes identification data as indicated.
CARBURETOR
| (1) | (2) | (3) | (4) | (5) | (6) | ||||||||||||
| 1 | 5 | 645 | 7 | F | 100025 | ||||||||||||
|
|||||||||||||||||
CAPACITIES
| Crankcase 427" Corvette | (1) 5 qts. | |||||||||
| All Others | (1) 4 qts. | |||||||||
| Cooling 283" V8 | (2) 15 qts. | |||||||||
| 327" Except Corvette | (2) 14 qts. | |||||||||
| Corvette | (2) 15 qts. | |||||||||
| 396" | (2) 22 qts. | |||||||||
| 427" 390 HP | (2) 21 qts. | |||||||||
| All Others | (2) 22 qts. | |||||||||
| Synchro-mesh 3-Speed | 2 pts. | |||||||||
| 4-Speed | 2 1/2 pts, | |||||||||
| Overdrive | 3 pts. | |||||||||
| Powerglide Refill | 3 pts. | |||||||||
| Overhaul (Water Cooled) | 20.1 pts. | |||||||||
| (Air Cooled) | 17.7 pts. | |||||||||
| Turbo Hydra-matic Refill | 8 pts. | |||||||||
| Overhaul | 19 pts. | |||||||||
| Rear Axle (Small Carrier) | 3 1/2 pts. | |||||||||
| (Large Carrier) | 4 1/2 pts. | |||||||||
| Fuel Tank V8 (Except Station Wagons) | 20 gal. | |||||||||
| (Station Wagons) | 23.8 gal. | |||||||||
|
||||||||||
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.