Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2001 Volvo S40FACTORY OEM SERVICE PROCEDURE
Electrical Component Locator: Connectors
CONNECTORS LOCATION
| Component | Component Location |
|---|---|
| 24/11 (22 Pin) | Below left rear seat. |
| 24/12 (4 Pin) | Below left rear seat. |
| 24/13 (8 Pin) | Below left rear seat. |
| 24/14 (20 Pin) | Left "A" pillar. |
| 24/15 (20 Pin) | Right "A" pillar. |
| 24/16 (10 Pin) | Left "B" pillar. |
| 24/17 (10 Pin) | Left "C" pillar. |
| 24/18 (14 Pin) | Behind left end of dash. |
| 24/19 (2 Pin) | Behind left side of dash. |
| 24/20 (22 Pin) | Behind left end of dash. |
| 24/21 (3 Pin) | Behind left side of dash. |
| 24/23 (22 Pin) | Under front of center console. |
| 24/24 (12 Pin) | Under front of center console. |
| 24/26 (10 Pin) | Behind left side of dash. |
| 24/27 (8 Pin) | Left rear of engine compartment. |
| 24/29 (10 Pin) | Top of tailgate. |
| 24/30 (2 Pin) | Top of tailgate. |
| 24/31 (6 Pin) | Left rear corner of vehicle, near taillights. |
| 24/32 (10 Pin) | Left rear of engine compartment. |
| 24/33 (4 Pin) | Front of engine compartment. |
| 24/64 (12 Pin) | Left side of engine compartment. |
| 24/70 (8 Pin) | Left side of engine compartment. |
| 24/72 (8 Pin) | Rear of engine compartment. |
| 24/73 (6 Pin) | Left front of engine compartment. |
| 24/81 (22 Pin) | Under front of center console. |
| 24/82 (12 Pin) | Under front of center console. |
| 24/90 (6 Pin) | Rear of engine compartment. |
| 24/91 (4 Pin) | Left rear corner of vehicle. |
| 24/120 (8 Pin) | Below left rear seat. |
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.