Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2003 Mini Cooper Base, Automatic CVTFACTORY OEM SERVICE PROCEDURE
Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Tool Rental Program (SI M04 05 17)
- Integrated Measurement Interface Box - IMIB R2 V6 (M07 01 16)
- Test Kit For Electrical Contacts (M04 01 13)
- Crimping Pliers For Wire End Ferrules (M04 13 12)
- Mini Output Shaft Adapter Kit For Use With Hydraulic Wheel Bearing And Output Shaft Tool (M04 06 12)
- Workshop Efficiency Mobile Toolbox (M04 11 12)
- Cable Set For Test Box (M04 04 12)
- Mini Special Tool Storage Cabinet (M04 02 12)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Diagnosis Feedback Using ISTA (M07 05 06)
- ISTA Pc Client (M07 03 10)
- ISTA FASTA Data Not Available (M07 04 10)
- Integrated Measurement Interface Box - IMIB (M07 03 09)
- ISTA Test Plan Priority Error (M07 02 10)
- Integrated Measurement Interface Box - IMIB (M04 16 09)
- Activating ISTA In Offline Mode When ISIS Is Not Available (M07 02 09)
- Dis V57 Release Notes (M07 01 09)
- New Programming And Coding System: ISTA/P (M09 01 07)
- Dis V55 Release Notes (M07 07 08)
- Dis V54 Release Notes (M07 04 08)
- Dis V52 Release Notes (M07 11 07)
- Dis V52 Changes Based On Diagnosis Feedback (December 2007 Release) (M07 12 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Dis V51 Corrections Based On Diagnosis Feedback (September 2007 Release) (M07 03 07)
- CARTOOL Part Number Search (M04 08 07)
- Release Notes PROGMAN V22.1 And V22.1.1 And V22.1.2 (M09 05 06)
- Release Notes PROGMAN V22.0 And V22.0.1 (M09 04 06)
- Accessories Control Systems
- Key Remote Bar Codes (M61 01 03)
- Enabling Code Information (M09 02 11)
- Closed-Circuit Current Monitoring (M61 07 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Dis V57 Release Notes (M07 01 09)
- Navigation System Operating Software (SI M84 04 03)
- Dis V52 Release Notes (M07 11 07)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Brake Lights On With Ignition Off (M63 200 05)
- Replacement Of Instrument Cluster Fails Coding (M09 07 06)
- Battery Discharge With Key Inserted In Ignition Lock (M61 200 04)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Vehicle Memory (M09 01 02)
- Clock Inaccurate (M62 01 05)
- Rear Defogger Relay Clicks After Several Minutes Of Operation (M64 01 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Available Software For DISPLUS/Gt1/SSS (SI M00 02 04)
- Conversion USA - CANADA (M62 01 04)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- R50, R53; Speedometer Needle Vibrates (M62 200 04)
- Modified Vehicles (Installation Of Non-Approved Accessories) (M01 08 03)
- Transport Mode (M61 02 03)
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- Not Possible To Delete Faults In The MRS5K Using Quick Delete (SI M65 03 09)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M65 03 06)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M72 01 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Passenger Airbag Status Lamp (SI M72 01 05)
- Deactivation/Reactivation Of Airbags (SI M72 02 03)
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Remote Bar Codes (M61 01 03)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- Door Lock Striker Adapter For Adjusting Side Windows (M04 08 08)
- Door Wrench Adaptation (M04 05 08)
- Center Lock Button Malfunction (M61 203 04)
- BOWDEN Cable Inside Door Comes Loose (M51 05 06)
- Alarm Installation Kit P/N 82 11 0 300 295 (M65 02 02)
- Disabling Double Lock (M61 06 02)
- Automatic Trans
- Mini Operating Fluids (SI M00 02 02)
- Mini CVT Replacement Parts Warranty Extension: Additional 12 Months With Up To 50,000 Accumulated Miles (M01 05 14)
- Mini CVT Transmission Repair & Replacement Information (M24 01 03)
- CVT - Howling Noise From The Transmission (M24 02 06)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- Automatic Transmission (CVT) Tools (M04 01 06)
- HAZET Square Drive Set (M04 03 03)
- CVT Input Shaft Radial Oil Seal Leaking (M24 01 04)
- CVT Input Shaft Seal Tools (M04 04 04)
- Selector Shaft Seal Tools (M04 06 04)
- Square Drive Torque Wrench (M04 04 03)
- Service Action 6 - Flush And Replace CVT Transmission Oil On Mini Cooper (M24 01 02)
- Assorted Special Tools (M04 04 02)
- Auxiliary Emission Control Systems
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Enabling Code Information (M09 02 11)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Evaporative System Tester (M04 05 06)
- Incorrect DME Programming (M12 08 05)
- Setting OBD Readiness Code Prior To State Inspection (M12 02 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- Test Cables (M04 02 02)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- Body Interior
- Key Remote Bar Codes (M61 01 03)
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Dis V57 Release Notes (M07 01 09)
- Navigation System Operating Software (SI M84 04 03)
- Dis V52 Release Notes (M07 11 07)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Brake Lights On With Ignition Off (M63 200 05)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Vehicle Memory (M09 01 02)
- Rear Defogger Relay Clicks After Several Minutes Of Operation (M64 01 05)
- Available Software For DISPLUS/Gt1/SSS (SI M00 02 04)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- Transport Mode (M61 02 03)
- Brakes Control Systems
- Enabling Code Information (M09 02 11)
- Magnetic Test Card For Wheel Speed Sensors (M04 01 12)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Charging Systems
- Electrical Contact Release Kit (M04 03 06)
- Closed-Circuit Current Monitoring (M61 07 07)
- DEUTRONIC Battery Chargers (M04 10 09)
- V & H MULTICHARGER 750 (M04 09 09)
- Wiring Harness Repairs (M61 02 07)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Assorted Special Tools (M04 04 02)
- Mini Special Tools (M04 01 02)
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- W10 Engine: Ems2K - Comprehensive Component OBD Readiness Monitor Not Completed (SI M12 08 17)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- ISTA Does Not Automatically Id The Vehicle (M07 06 10)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Fuel Line Plugs (M04 04 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Incorrect DME Programming (M12 08 05)
- DME (Ems2000 Or Ms5150) Fault Code P0128 - Coolant Thermostat (M12 201 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Powertrain DRIVEABILITY Complaints (M12 202 04)
- Power Steering Pump Cooling Fan Activation (M32 01 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- Test Cables (M04 02 02)
- Entertainment Systems
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- BLUETOOTH: IPHONE Is Not Displayed In The List Of Paired Devices (SI M84 02 12)
- SIRIUSXM Satellite Radio: How It Works (SI M65 04 12)
- USB Audio Interface (M65 01 09)
- Entertainment And Communication Systems Are Inoperative Intermittently (M65 02 11)
- Champ2 - Navigation System Road Map Move (M65 01 11)
- Real Time Traffic Information (SI M65 07 10)
- Power Port Release Tool (M04 02 10)
- Audio Complaints Relating To Audio Cd/Audio DVD Drive (SI M65 11 08)
- Dis V52 Release Notes (M07 11 07)
- Rattling Noise From Loudspeaker / Door Panel (M51 02 06)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Mp3 Player Will Not Work On Vehicles With An In-Dash Cassette Radio (SI M65 04 03)
- "Reg Off" Displayed On NG C53 Cassette Radio (M65 02 03)
- Speed Dependent Volume Function Is Not Adjustable (M65 01 03)
- Business Cd53 Radio Has Distortion When In Am Band (SI M65 03 02)
- Alpine I Bus Cd Changer Installation Kit P/N 82 11 0 147 417 (M65 01 02)
- Exhaust
- Exterior Body Panels
- Tool For Setting Hood Into Service Position (M04 03 13)
- Hand-Held Riveting Tool (M04 02 09)
- Door Wrench Adaptation (M04 05 08)
- Tailgate Is Difficult To Open And/Or Close (M41 01 07)
- Corrosion On Door Seal Flange (M41 02 06)
- Hose Guide Tool (M04 06 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Or Squeaking Noises Heard From The Door/Window (M51 07 05)
- Paint Damaged Under Hood (M41 200 03)
- Rattles From Rear Hatch (M41 01 02)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Hood Grille Is Loose Or Rattles (M51 04 02)
- Exterior Lights
- Light Bulb Replacement - Incandescent And Halogen Light Bulbs (M63 01 11)
- Automatic Headlights: Adjusting Sensitivity (M63 01 08)
- Headlamp Moisture: Fault Diagnostics (M63 03 09)
- Brake Lights On With Ignition Off (M63 200 05)
- Brake Lights Stay On All The Time (M63 202 05)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Modified Headlight Adjustment Tool (M04 03 05)
- Auxiliary Driving Light Installation Kit P/N 63 12 0 144 132 (M63 01 02)
- Mini Special Tools (M04 01 02)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuel Tank Siphon Kit - Gasoline (SI M04 03 18)
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- VACUTEC Leak Finder (M04 01 14)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Fuel Level Sensor Repair Procedure (M16 01 09)
- Alcohol Fuel Blends In Mini Vehicles (M13 01 06)
- Mini Fuel System Cleaner Plus (M13 05 06)
- Fuel Injection And Induction System Cleaning (M13 01 07)
- Fuel Composition Tester (M04 05 11)
- Testing Fuel Composition (M13 05 10)
- Hose Pinch Pliers (M04 04 11)
- Fuel Line Plugs (M04 04 09)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Fuel Level Sensor Repair Procedure (M16 01 09)
- Replacement Of Instrument Cluster Fails Coding (M09 07 06)
- Instrument Panel Noise (M51 08 05)
- Clock Inaccurate (M62 01 05)
- Conversion USA - CANADA (M62 01 04)
- R50, R53; Speedometer Needle Vibrates (M62 200 04)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Incorrect Lower Trim Panel (M51 01 03)
- Hazardous Waste Material
- Headlights
- Light Bulb Replacement - Incandescent And Halogen Light Bulbs (M63 01 11)
- Automatic Headlights: Adjusting Sensitivity (M63 01 08)
- Headlamp Moisture: Fault Diagnostics (M63 03 09)
- No Daytime Running Lights Available In CKM (M09 03 06)
- Modified Headlight Adjustment Tool (M04 03 05)
- Auxiliary Driving Light Installation Kit P/N 63 12 0 144 132 (M63 01 02)
- Mini Special Tools (M04 01 02)
- Heated Glass/Defoggers
- HVAC Control Systems
- Mini Operating Fluids (SI M00 02 02)
- Noise From RECIRCULATION Motors (M64 04 08)
- J-48943 A/C Service Unit (M04 19 09)
- A/C O-Ring Tool (M04 15 09)
- Brake Lights Stay On All The Time (M63 202 05)
- IHKA Intermittently Doesn't Switch On (M64 202 04)
- Air Conditioning System Musty Odor (M64 01 06)
- Whistling At Speeds Of Over 50 Mph From The Heater (M64 01 04)
- Air Conditioning Doesn't Cool (M64 02 05)
- A/C Does Not Blow Cold Air (M64 02 04)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Navigation System Has Missing Or Incorrect Road Map Data (SI M65 06 10)
- Antenna Test Cables (M04 04 16)
- Entertainment And Communication Systems Are Inoperative Intermittently (M65 02 11)
- Champ2 - Navigation System Road Map Move (M65 01 11)
- Real Time Traffic Information (SI M65 07 10)
- Navigation System Operating Software (SI M84 04 03)
- R50 (Cooper), R53 (Cooper S) With Navigation System (Option 609): Board Monitor Start-Up Delay, Not Temperature Related (SI M65 200 04)
- MK3: Start-Up Delay At Temperatures Below 37 Degrees F (SI M84 03 03)
- Interior/Exterior Trim
- Mini Vehicles - Leather Care (SI M00 03 19)
- Rear License Plate Bracket: Seized Screws (M51 04 13)
- Floor Mat Awl (M04 12 07)
- Installation Roller (M04 08 06)
- Instrument Panel Noise (M51 08 05)
- Creaking Noise When Driving From Heating And Air Conditioning Housing Area (M51 07 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Noise From Loudspeaker / Door Panel (M51 02 06)
- Rear Cup Holder Bezel Is Loose (M51 15 05)
- Cracked Outside A-Pillar Trim (M51 06 05)
- Glove Box Difficult To Latch Or Open (M51 200 04)
- Glove Box Does Not Open (M51 201 04)
- Outside A-Pillar Trim Torn Off (M51 202 04)
- Dimples In Roof Panel - Cars Without Sunroof (M41 01 03)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Incorrect Lower Trim Panel (M51 01 03)
- Hood Grille Is Loose Or Rattles (M51 04 02)
- Interior/Illumination Lights
- Lubrication System
- Engine Oil Pressure Diagnosis Hints (SI M11 02 23)
- External Engine Oil Leaks And Repairs (SI M01 05 21)
- Engine Replacement And Engine Repairs (M11 04 15)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- Oil Seepage From The Filter Housing Area (M11 01 06)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Replacement Oil Filters (M00 06 02)
- Mini Special Tools (M04 01 02)
- Manual Steering
- Mini Operating Fluids (SI M00 02 02)
- Replacement Of Steering Gear Due To Accident Damage (M32 04 05)
- Electro-Hydraulic Power-Assist Steering Pump (EHPS) And Cooling Fan: Limited Warranty Extension To 13 Years/150,000 Miles (M01 01 13)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Power Steering Pump Noise (M32 200 04)
- Power Steering Pump Cooling Fan Activation (M32 01 04)
- Manual Trans
- Mini Operating Fluids (SI M00 02 02)
- Mini With Manual Transmission - "Stiff" Diagonal Gearshift (M23 03 08)
- Extractor For Rotary Shaft Seal - GS5 And GS6 Transmissions (M04 07 09)
- Replacement Of Output Shaft Seal - Manual 5-Speed (M23 04 08)
- Transmission Shifting Cables Frozen (M25 200 04)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- HAZET Square Drive Set (M04 03 03)
- Hydraulic Clutch Control Repair And Bleeding Procedures (M21 02 05)
- Mini Special Tools (M04 02 05)
- Rattling Noises From The Shift Cable Area (M25 01 04)
- Square Drive Torque Wrench (M04 04 03)
- Assorted Special Tools (M04 04 02)
- Mechanical
- Engine Replacement And Engine Repairs (M11 04 15)
- Crankshaft Seal And Bed Plate Liquid Sealer (M11 11 16)
- Engine Oil Consumption (M11 02 13)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- Engine Oil Is Below The Minimum Level (M01 05 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Valve Guide To Valve Stem Wear Specification (M11 06 14)
- Engine Oil Residue Found Near Oil Filler Cap (M11 05 14)
- VACUTEC Leak Finder (M04 01 14)
- Engine Cross-Member And Supports (M04 10 11)
- New Engine Support Part Numbers (M04 03 09)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Engine, Transmission, Or Clutch Related Complaints (M11 02 06)
- HAZET Square Drive Set (M04 03 03)
- Oil Seepage From The Filter Housing Area (M11 01 06)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- New Mini Tools (M04 02 04)
- Special Tools (M04 06 03)
- Square Drive Torque Wrench (M04 04 03)
- Assorted Special Tools (M04 04 02)
- Replacement Oil Filters (M00 06 02)
- Mini Special Tools (M04 01 02)
- Mechanical - Hydraulic
- Vibration When Braking: Diagnosing And Repairing (M34 02 15)
- Brake Pad Maintenance Services: Brake Disc Resurfacing Guidelines (SI M34 04 16)
- On-Car Brake Lathe (SI M34 05 16)
- Mini Operating Fluids (SI M00 02 02)
- Brake Disc And Brake Pad Service And Reference Information (M34 01 14)
- Brake Rotor Minimum Thickness (M34 01 10)
- Brake Rotor Puller (M04 13 09)
- Sticking Rear Brake Calipers (M34 02 05)
- Mini Special Tools (M04 01 02)
- Memory Modules
- Mirrors
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Seat Heaters Too Hot Or Too Cold (M61 01 04)
- Front Seat Backrest Difficult To Recline (M52 02 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Rattles From Rear Seat Backrest (M52 01 03)
- Squeaks From Seat Cushion Frame (M52 05 02)
- Troubleshooting Noises From Front Seat Backrest (M52 04 02)
- Front Seat Backrest Inoperative (M52 01 02)
- Seat Lever Tool (M04 05 02)
- Procedures
- Mini Dealer Self-Authorized (DSA) Goodwill And The Elite Shop Programs (SI M01 06 03)
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Mini Engine Oil (SI M11 01 21)
- Mini Alternate Transportation Measures (ATM): Amp And Rental Vehicles (SIM 01 02 21)
- The New Mini Dealer Retail Audit Approach (SI M00 02 21)
- What's New In ISPI Next 20.2 (SI M05 01 20)
- Mini Warranty Simplification Program (WSP) Diagnosis Work Time Flat Rate Concept (SI M01 04 20)
- Mini Warranty Simplification Program (WSP) Standard Variable Diagnosis Work Time (SI M01 01 20)
- QCI Claim Payment And Process Change (SI M01 01 08)
- Mini MOTORER Obsession (Reboot): Non-Repair Customer Goodwill Initiative (SI M01 09 14)
- BMW Group Technical Support And New TSARA Hotline (TRI M00 02 19)
- TIS 2.0 Launches On December 13TH (SI M10 01 18)
- IRAP Control Unit Recovery (SI M09 01 18)
- Mini Engine: Oil Repair Order Invoicing Procedure (SI M01 04 15)
- Mini Recall/Service Action Repairs Alternative Mobility Solutions (AMS) (SI M01 01 17)
- Tool Rental Program (SI M04 05 17)
- IRAP Next (SI M09 01 16)
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- New Enrollment Procedure For Mini Maintenance Plan Upgrade To 4/50 (M01 09 03)
- Mini Full Maintenance Program 3 Years - 36,000 Miles And Full Maintenance Upgrade To 4 Years - 50,000 Miles (M01 01 03)
- Rear Suspension
- Restraints Control Systems
- Enabling Code Information (M09 02 11)
- Airbag Warning Light Is On: MRS FC 02, 03, 05, 06 (SI M72 01 03)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Not Possible To Delete Faults In The MRS5K Using Quick Delete (SI M65 03 09)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M65 03 06)
- Airbag Warning Lamp For OC3 Seat Mat Fault (SI M72 01 06)
- Passenger Airbag Status Lamp (SI M72 01 05)
- Deactivation/Reactivation Of Airbags (SI M72 02 03)
- Schedule
- CPO (Mini Next) Inspection Guidelines: Engines Requiring A Technical Puma Case (M11 03 13)
- 60-Day Bundling Of Maintenance Services For MOTORER Satisfaction (M01 06 13)
- Mini Maintenance Program: Annual Low-Mileage Engine Oil Changes (M01 02 03)
- New Enrollment Procedure For Mini Maintenance Plan Upgrade To 4/50 (M01 09 03)
- Mini Full Maintenance Program 3 Years - 36,000 Miles And Full Maintenance Upgrade To 4 Years - 50,000 Miles (M01 01 03)
- Seats
- Required Hardware Replacements During Seat Service/Repair (SI M52 02 19)
- Mini Vehicles - Leather Care (SI M00 03 19)
- Seat Occupancy Adapter Cable (OC3) - ITOOLS (M04 09 08)
- Seat Heaters Too Hot Or Too Cold (M61 01 04)
- Front Seat Backrest Difficult To Recline (M52 02 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Recycling Or Disposal Of Airbags And SEATBELT PRETENSIONERS (M01 05 05)
- Rattles From Rear Seat Backrest (M52 01 03)
- Squeaks From Seat Cushion Frame (M52 05 02)
- Troubleshooting Noises From Front Seat Backrest (M52 04 02)
- Front Seat Backrest Inoperative (M52 01 02)
- Seat Lever Tool (M04 05 02)
- Starter
- Battery Maintenance Requirements: Battery Care (SI M61 01 02)
- Approved Battery Charger/Power Supplies (M04 08 09)
- Transport Mode Switching Device: TMSD (M04 11 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- EXIDE Replacement Batteries (M01 09 13)
- Updated Battery Registration Procedure (M61 03 12)
- Closed-Circuit Current Monitoring (M61 07 07)
- DEUTRONIC Battery Chargers (M04 10 09)
- V & H MULTICHARGER 750 (M04 09 09)
- Vehicle Battery Charging Voltage (M04 07 06)
- Battery Discharge With Key Inserted In Ignition Lock (M61 200 04)
- Correct Routing Of Battery Vent Tube (M61 03 02)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Steering Column
- Steering Control Systems
- Mini Operating Fluids (SI M00 02 02)
- Electro-Hydraulic Power-Assist Steering Pump (EHPS) And Cooling Fan: Limited Warranty Extension To 13 Years/150,000 Miles (M01 01 13)
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Various Complaints Caused By Damaged Engine Harness (M12 05 05)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Power Steering Pump Noise (M32 200 04)
- Steering Gear
- Steering Linkage
- Required Hardware Replacement During Wheel Alignments (SI M32 01 18)
- New Installation Of Right-Hand Drive Steering Spindle In Left-Hand Drive Vehicle Is No Longer Required (M32 02 14)
- Replacement Of Steering Gear Due To Accident Damage (M32 04 05)
- Wheel Alignment Data (M32 01 08)
- New Mini Tools (M04 02 04)
- Sun Roof/T-Top/Convertible Top
- Mini Operating Fluids (SI M00 02 02)
- Test Plans For Panoramic Roof (M54 01 11)
- Various Noises From The Convertible Top (M54 01 10)
- Dis V52 Release Notes (M07 11 07)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Sunroof Cassette Screw Tool (M04 01 04)
- Squeaking Noise When Operating Sunroof (M54 01 04)
- Dimples In Roof Panel - Cars Without Sunroof (M41 01 03)
- Troubleshooting Sunroof Squeaks And Rattles (M54 01 02)
- Suspension Control Systems
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Wheel Alignment Data (M32 01 08)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Illuminated Dynamic Stability Control (DSC) Light (M34 201 03)
- Tire Pressure Monitoring Systems (TPMS) (M36 02 05)
- System
- High-Pressure Direct Injection Fuel System Repairs (M13 02 15)
- Mini Operating Fluids (SI M00 02 02)
- Crankcase Ventilation System Diagnosis And Measurement (M11 07 08)
- Key Reader Error: Fuel System Additive On Service Check Sheet (M00 08 14)
- Remote Control And Comfort Access/Passive Go Is Inoperative (SI M66 01 12)
- VACUTEC Leak Finder (M04 01 14)
- State Inspection And Emission (I/M) Test Fails Due To An Invalid VIN Number (M12 02 13)
- Top Tier Detergent Gasoline In Mini Vehicles (M13 02 06)
- Enabling Code Information (M09 02 11)
- Service Engine Soon Lamp Illuminated: FC 130 Oxygen Sensor (M12 06 07)
- Spark Plug Application (M12 01 02)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- Fuel Line Plugs (M04 04 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Special DME And EGS Programming - Shipping Procedure (M12 03 04)
- Fuel Injection And Induction System Cleaning Tool Hose Replacement (M04 17 07)
- Fuel Injection And Induction System Cleaning (M04 07 07)
- Run Test Modules To Completion (M07 10 07)
- TEILECLEARING (Enhanced Technical Support) For DME (M12 09 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Evaporative System Test ADAPTOR (M04 06 07)
- Testing Evaporative System For Leaks (M16 01 07)
- Testing Induction Systems Using The VACUTEC® Smoke Machine (M11 04 07)
- Ems2K FC 2096 - Post-Cat Oxygen Sensor Lean Mixture (M12 01 06)
- Ems2K/Ms5150 Reprogramming Helpful Hints (M12 200 03)
- Hose Guide Tool (M04 06 06)
- Alcohol Detection Procedure (M13 04 06)
- Ems2K - FC P0128; Coolant Thermostat (M12 03 06)
- Evaporative System Tester (M04 05 06)
- Fuel Pump Failure After Refueling With Ethanol Fuel Blend (M13 03 06)
- EDK Throttle Faults On W10/W11 Engines - Diagnostic Procedure (M12 04 02)
- Incorrect DME Programming (M12 08 05)
- DME (Ems2000 Or Ms5150) Fault Code P0128 - Coolant Thermostat (M12 201 05)
- Battery Draw Since The IPOD Is Installed (SI M65 200 05)
- Setting OBD Readiness Code Prior To State Inspection (M12 02 04)
- Powertrain DRIVEABILITY Complaints (M12 202 04)
- DRIVEABILITY Complaints - DME Programming (M12 02 03)
- Test Cables (M04 02 02)
- Transfer Case
- Transmission Control Systems
- Enabling Code Information (M09 02 11)
- ISTA Fault Code "S0001" Entries Still Present After Quick Delete (M07 01 10)
- ICOM Extension Cable (M04 11 09)
- R50/R52 CVT; Engine Speed Flaring On Deceleration (M24 01 09)
- Run Test Modules To Completion (M07 10 07)
- Importance Of Using The Most Current Diagnostic/Programming Software (M07 08 07)
- Wheel Alignment
- Wheels & Tire System
- Tire Valve Torque Wrench (SI M04 04 18)
- Stripped Locking Wheel Bolts (M04 05 16)
- New Installation Of Right-Hand Drive Steering Spindle In Left-Hand Drive Vehicle Is No Longer Required (M32 02 14)
- New Wheel Balancing Adapter Kit (M04 02 14)
- Mini Tire Center Target Satisfaction Program (M01 01 04)
- Adjusting Tire Pressures (M36 02 10)
- Hunter GSP97BMW Wheel Balancer - Features And Operator Training (M36 01 04)
- Nitrogen Inflated Tires (M36 01 06)
- Tire Pressure Monitoring Systems (TPMS) (M36 02 05)
- Window Motors & Regulators
- Wire Pull Handle With Suction Cup For Windshield Removal (M04 09 12)
- Cracked Or Damaged Windshield (M51 01 09)
- Door Lock Striker Adapter For Adjusting Side Windows (M04 08 08)
- Mini Glass Repair (M02 03 06)
- Slow Power Window Operation (M51 08 06)
- Solutions Overview For Noise Complaints (SI M00 04 06)
- Rattling Or Squeaking Noises Heard From The Door/Window (M51 07 05)
- Cracked Outside A-Pillar Trim (M51 06 05)
- Windshield Water Ingress (M51 13 05)
- Windshield Exhibits Stress Cracks After Replacement Of Windshield (M51 201 03)
- Windows Do Not Drop When Opening Door (M61 03 03)
- Body Squeaks And Rattles Troubleshooting Guide (M51 05 02)
- Assorted Special Tools (M04 04 02)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.