Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2023 Mercedes Benz Sprinter 2500 Van Cargo Extended, RWDFACTORY OEM SERVICE PROCEDURE
Labor Times: Other Variant
WARNING: This page is about the Sprinter 2500 Van Cargo, Eng CD 654.920, 4WD, which is a different variant/trim than selected.
- Accessories and Equipment
- Drivelines and Axles
- Engine Mechanical
- Auxiliary Emission Control Systems
- EGR By-Pass Valve
- EGR Cooler
- EGR Pressure Sensor
- EGR Switch-Over Valve
- EGR System
- EGR Tube
- EGR Valve
- Engine Emission System
- Exhaust AFTERTREATMENT System
- Exhaust AFTERTREATMENT System Control Unit
- Particulate Filter Assembly
- Particulate Filter Pressure Sensor
- Particulate Filter Temperature Sensor
- Particulate Filter THERMO Sensor
- PCV Heater
- PCV Hose
- PCV Valve
- REDUCTANT Fluid Additive
- REDUCTANT Fluid Injector
- REDUCTANT Fluid Metering Control Module
- REDUCTANT Fluid Pump
- REDUCTANT Fluid Tank
- REDUCTANT Fluid Tank Filler Neck
- Vacuum Reservoir
- Fuel Systems
- Glow Plugs
- Lubrication Systems
- Mechanical
- Balance Shaft
- Camshaft
- Camshaft Timing
- Connecting Rod Bearings
- Crankcase Cover
- Crankshaft
- Crankshaft Oil Seal
- Crankshaft Pulley
- Cylinder Head Cover
- Cylinder Head Gasket
- Engine Assembly
- Engine Assembly (Complete)
- Long Block
- Rocker Arm
- Short Block
- Timing Chain
- Timing Chain TENSIONER
- Timing Chain TENSIONER Rail
- Timing Cover &/Or Gasket
- Valve
- Valve Cover Gasket
- Valve Lifters
- Valve Spring Or Seal
- Auxiliary Emission Control Systems
- Engine Performance
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- Automatic HVAC System
- Heater
- HVAC Control Systems
- Manual HVAC System
- Restraints
- Steering
- Suspension
- Front Suspension
- Rear Suspension
- Suspension Control Systems
- Wheel and Tire Systems
- Transmission
- Automatic Trans
- Clutch Manual and Hydraulic
- Transfer Case
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.