Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2007 Mazda 6 L4-2.3LFACTORY OEM SERVICE PROCEDURE
Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Steering - Steering Wheel Off Center When Driving Straight
- Interior - Seats Shake/Make Noise When Braking
- Tire Monitor System - Warning Lamp ON/Low Tire Pressure
- Engine - VVT Noise At Engine Start Up
- Steering/Suspension - Steering Wheel Off-Center
- Exhaust System - Rubbing Noise At Idle
- Body - Wind Noise From Around Windows
- AT, Engine Controls - ECM/TCM Update
- Engine - MIL ON/DTC P2006 Set
- Navigation System - Displays No or Incorrect Map
- Interior - Manual Lumbar Support Inoperative
- Engine Controls - Engine Stalling at Low Speeds
- Engine Controls - Engine Stalls Driving at Low Speeds
- Navigation System - Displays Incorrect Map or No Map
- Drivetrain - Front Axle Knocking Noises in Extreme Cold
- Steering - Steering Shaft Clunk on Acceleration/Turns
- Electrical - No Start/A/C, Defroster Inoperative
- Steering - Drift/Pull Diagnostics
- Wheels - Rust On Steel Wheel Surfaces
- Body - Windows Open Unintentionally
- Engine Controls - MIL ON/DTC P0601 Set
- Engine - No Start/Scraping Noise/Engine Damage
- Body - Various Wind Noise Concerns
- Brakes - Park Brake Lever Drops Down After Engagement
- A/C - Musty/Mildew Odor Elimination
- M/T - Clutch Is Difficult To Operate
- M/T - Hard To Shift Into 1st/2nd Gear
- Engine - Unstable Idle/Engine Stalling
- Emissions - MIL ON/DTC P0441 Set
- A/C - Musty/Mildew Odors From vents
- Overview
- Repair Procedures
- Information
- 2007-2009 CX-9 Front A/C/2007-2009 CX-9 Rear A/C
- 2007-2009 CX-7
- 2003-2008 MAZDA6
- 1998-2002 626
- 2004-2009 MAZDA3
- 1998-2003 Protege and PROTEGE5
- 2000-2003 MPV Front A/C/2000-2003 MPV Rear AC (if equipped)
- 1998 MPV Front A/C/1998 MPV Rear A/C (if equipped)
- 2001-2002 Millenia (With Cabin Air Filter)
- 1998-2000 Millenia
- 2006-2008 MX-5
- 1999-2005 Miata
- Exhaust System - Rubbing Noises At Idle
- Interior - Driver's Seat Chatters/Seat Lift Inoperative
- Interior - Front Seat Clunk Noise While Braking
- Interior - Leather Seat Squeaking Noises
- Interior - Front Seat Head Rest Rattling Noises
- Interior - Front Seat Back Squeaking Noises
- Interior - Squeaking Noise From Under The Driver's Seat
- Interior - Seat Back Squeaking Noises
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456 Set
- A/T - 3-4 Shift Shock Under Load
- Steering - Steering Wheel Off Center, No Pull Or Drift
- Superceded Bulletins
- 0902812 - 08/10/12
- 0000309 - 01/12/09
- 0102906 - 07/28/06
- 0700607 - 10/15/08
- 0200104 - 01/15/08
- 0100308 - 02/07/08
- 0900507 - 02/15/07
- 0900806 - 03/17/06
- 0102207 - 06/08/07
- 0900306 - 01/26/06
- 0104606 - 11/09/06
- Lighting - Excessive Water/Condensation In Headlamps
- Lighting - Headlight Lens Condensation or Water Entry
- Lighting - Condensation In Front/Rear Lamps
- Lighting - Moisture In Front/Rear Lamps
- Interior - Unable to Adjust Driver's Seat Manual Lift
- 0904108 - 12/19/08
- Interior - Seats Noisy/Shake Back And Forth When Braking
- Body - Paint Damage Repair Guide
- Interior - Avoiding Driver Floor Mat/Pedal Interference
- Keyless Entry - Trunk Request Switch Inoperative
- Audio System - SIRIUS(R) Radio System Activation
- Navigation System - Service Information
- Keyless Entry - Trunk Request Switch is Inoperative
- Instruments - Navigation/Multi-Information Display Service Inf
- Restraints - Passenger Air Bag Deactivation Lamp ON
- Interior - Poor Dash Surface Appearance
- A/C - Musty/Mildew Odors From Vents
- Suspension - Strut/Shock Replacement Guidelines
- Suspension - Strut/Shock Absorber Replacement Guidelines
- Suspension - Shock/Strut Replacement Guidelines
- Steering - Clunk Noise When Turning Steering Wheel
- Electrical - Battery Testing Procedures
- Electrical - Battery Testing Procedure Requirements
- Electrical - Battery Testing/Charging Procedures
- Electrical - Battery Test Procedures
- Brakes - Noise/Judder/Dragging
- M/T - Clutch Pedal is Difficult To Operate
- A/T - Cooler/Line Flushing Procedure
- A/T - Cooler Line Flushing Procedure
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456
- 0104207 - 12 07 07
- Engine Controls - Oxygen Sensor Removal Precautions
- Engine Controls - Oxygen Sensor Removal Precaution
- Engine Controls - O2, A/F Sensor Removal Precautions
- Exhaust System - Excessive Sulfur Odors
- Exhaust System - Rubbing Noises at Idle
- Exhaust System - Rubbing Noise at Idle or Shut Down
- Engine - Crankshaft Pulley Service Precautions
- 0104307 - 12/07/07
- Engine - VVT Noise At Engine Start Up
- Steering/Suspension - Pull/Drift Diagnosis & Repair
- Steering/Suspension - Pull or Drift While Driving
- A/T - Fluid Usage/Applications
- Steering - Steering Wheel Is Off Center
- A/T - Correct Fluid Applications
- All Technical Service Bulletins
- Instruments - Navigation/Multi-Information Display Service Info
- Interior - Poor Upper Dash Surface Appearance
- Steering - Steering Wheel Off Center When Driving Straight
- Interior - Seats Shake/Make Noise When Braking
- Restraints - Passenger Air Bag Indicator (PAD) Information
- Electrical - Battery Maintenance Information
- Electrical - Battery Testing Procedures
- Body - Paint Damage Repair Guide
- Exhaust System - Excessive Sulfur Odors
- Tire Monitor System - Warning Lamp ON/Low Tire Pressure
- Engine - VVT Noise At Engine Start Up
- Steering/Suspension - Steering Wheel Off-Center
- Brakes - Judder/Dragging Diagnostic Information
- A/T - Cooler Line Flushing Procedures
- Instruments - Ambient Temperature Display Inaccurate
- A/T - Diagnostic Procedures
- Exhaust System - Rubbing Noise At Idle
- Interior - Console Damage Prevention During Removal
- Audio System - iPod(R) Adapter Application Table
- Fuel System - Fuel Ethanol Content Testing
- Instruments - Info. Display Full Afetr Remote Start
- Computers/Controls KAM Memory Clearing After VVT R & R
- Navigation System - Beep Sound From Dash While Driving
- Audio System - Satellite Radio Serial Number Retrieval
- A/T - Speed Sensor Replacement
- Body - Window Regulator Replacement
- Mirrors - Door Mirror Glass Is Loose
- Tire Monitor System - Can't Turn OFF/On Reprogram
- M/T - 4th Gear Service Precautions
- Engine - Correct Oil Filter Wrench Applications
- A/C - Poor Blower Motor Performance
- Engine - Camshaft Timing Information
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Body - Front End Pop Noise Over Bumps
- Electrical - Battery Maintenance
- Ignition System - Spark Plug Removal/Installation
- Body - Wind Noise From Around Windows
- AT, Engine Controls - ECM/TCM Update
- Electrical - Battery Charging Precautions
- Air Bag System - Affect of Accessories On Air Bag Sys.
- Keyless Entry - Security Access Procedure
- Engine - MIL ON/DTC P2006 Set
- Cooling System - Reconditioned Coolant Recommendations
- Navigation System - Displays No or Incorrect Map
- Interior - Manual Lumbar Support Inoperative
- Engine - Front Crankshaft Bolt Service Precautions
- Wheels - Stain Prevention Information
- Engine Controls - Engine Stalling at Low Speeds
- Recall - ECM Update for OBD Functions
- Cooling System - Pre-Mixed Long-Life FL22 Coolant Info.
- Keyless Entry - Transmitter Specification Change
- Keyless Entry - Remote Transmitter Specification Change
- Engine Controls - Engine Stalls Driving at Low Speeds
- A/T - Range Switch Removal/Installation Caution
- Fuel System - Servicing Precautions
- Navigation System - Displays Incorrect Map or No Map
- Drivetrain - Front Axle Knocking Noises in Extreme Cold
- Steering - Steering Shaft Clunk on Acceleration/Turns
- Electrical - No Start/A/C, Defroster Inoperative
- Steering - Drift/Pull Diagnostics
- Wheels - Rust On Steel Wheel Surfaces
- Body - Windows Open Unintentionally
- Computers/Controls - Module Reprogramming Precautions
- Engine Controls - MIL ON/DTC P0601 Set
- Recall 08V412000: Fuel Tank Repair/Replacement
- Engine - Oil Filter Element Replacement Precautions
- Engine - No Start/Scraping Noise/Engine Damage
- Engine Controls - Revised DTC P0441 Diagnostics
- Audio System - Sirius Satellite Radio(R) Activation
- Body - Various Wind Noise Concerns
- Brakes - Park Brake Lever Drops Down After Engagement
- A/C - Musty/Mildew Odor Elimination
- M/T - Clutch Is Difficult To Operate
- Recall - Fuel Tank Inspection/Replacement
- M/T - Hard To Shift Into 1st/2nd Gear
- Cooling System - Small Water Pump Leak Explanation
- Engine - Unstable Idle/Engine Stalling
- Emissions - MIL ON/DTC P0441 Set
- Interior, A/C - Seat Heater Inspection Procedures
- Body - Rear Quarter Glass Replacement Precaution
- A/C - Musty/Mildew Odors From vents
- Overview
- Repair Procedures
- Information
- 2007-2009 CX-9 Front A/C/2007-2009 CX-9 Rear A/C
- 2007-2009 CX-7
- 2003-2008 MAZDA6
- 1998-2002 626
- 2004-2009 MAZDA3
- 1998-2003 Protege and PROTEGE5
- 2000-2003 MPV Front A/C/2000-2003 MPV Rear AC (if equipped)
- 1998 MPV Front A/C/1998 MPV Rear A/C (if equipped)
- 2001-2002 Millenia (With Cabin Air Filter)
- 1998-2000 Millenia
- 2006-2008 MX-5
- 1999-2005 Miata
- Body - Engine Compartment Shroud Appearance
- Lighting - Plastic Headlamp Lens Maintenance Cautions
- Engine - Component/Engine Replacement Guidelines
- Engine - Noise Diagnostic Information
- Exhaust System - Rubbing Noises At Idle
- Interior - Driver's Seat Chatters/Seat Lift Inoperative
- Interior - Front Seat Clunk Noise While Braking
- Interior - Leather Seat Squeaking Noises
- Interior - Front Seat Head Rest Rattling Noises
- Interior - Front Seat Back Squeaking Noises
- Interior - Squeaking Noise From Under The Driver's Seat
- Interior - Seat Trim Replacement Procedure
- Interior - Seat Back Squeaking Noises
- Body - Windshield Flaw/Scratch/Crack Information
- Navigation System - Display Standard For Failed Pixels
- Battery - Testing Information
- Wipers/Washers - Wiper Blade Insert Replacement
- Engine Controls - O2 Sensor Removal Precautions
- Electrical - Battery Eye Condition Monitor Information
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456 Set
- A/T - 3-4 Shift Shock Under Load
- Keyless Entry - Transmitter Battery Replacement Cautions
- Fuel System - Ethanol Fuel Usage
- Suspension - Shock Absorber/Strut Replacement Guidelines
- Lighting - Condensation In Front/Rear Combination Lamps
- Lighting - Excessive Condensation In Headlamps
- Steering - Steering Wheel Off Center, No Pull Or Drift
- A/T - ATF Applications
- Interior - Proper Floor Mat Usage And Installation
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.