Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2007 Mazda 5 L4-2.3LFACTORY OEM SERVICE PROCEDURE
Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Steering - Steering Wheel Off Center When Driving Straight
- Interior - Seats Shake/Make Noise When Braking
- Drivetrain - Drive Axle Clunking Noises
- Tire Monitor System - Warning Lamp ON/Low Tire Pressure
- Suspension - Front/Rear Knock/Rattle/Squeak On Bumps
- Engine - VVT Noise At Engine Start Up
- Steering/Suspension - Steering Wheel Off-Center
- Restraints - Air Bag Lamp ON/DTC B1881 Set
- Emissions - MIL ON/DTC's P2401/P2402/P2404 Stored
- Restraints - Air Bag Lamp ON/DTC's B2856/B104D/B2227
- Engine/Fuel - MIL ON/DTC P2006 Stored
- Body - Wind Noise From Around Windows
- AT, Engine Controls - ECM/TCM Update
- Navigation System - Displays No or Incorrect Map
- Ignition System - Idle Fluctuation/Engine Vibration
- Engine Controls - Engine Stalling at Low Speeds
- Body - Uneven Clearance Between Liftgate & Rear Lamps
- Interior - C-Pillar Trim Deformed Upon Re-Installation
- Body - Rear Sliding Door Latch Screws Corroded
- Engine Controls - MIL ON/DTC P0128 Stored
- Engine Controls - Engine Stalls Driving at Low Speeds
- Engine Controls - Intermittent Engine Stumble
- Restraints - Seat Belt Retainers Broken
- Navigation System - Displays Incorrect Map or No Map
- Steering - High Power Steering Effort
- Body - Wind Noise/Whistle From Outer Mirrors
- Engine - Unstable Idle/Engine Stalling
- Emissions - MIL ON/DTC P0441 Set
- Interior/Restraints - Seat Belt Buckle Rattles/Squeaks
- A/C - Stops Cooling After Long Drive When Hot/Humid
- Body - Sliding Door Lock Hard To Operate
- Engine - Knocking Noise On Start Up/Shut Down
- Interior - Driver's Seat Chatters/Seat Lift Inoperative
- Interior - Front Seat Clunk Noise While Braking
- Interior - Leather Seat Squeaking Noises
- Interior - Front Seat Head Rest Rattling Noises
- Interior - Front Seat Back Squeaking Noises
- Interior - Squeaking Noise From Under The Driver's Seat
- Interior - Seat Back Squeaking Noises
- Keyless Entry - Remote Transmitter Is Inoperative
- Interior, A/C - Knob Comes Off Of R/H Dash Vent
- Body - Front Door Power Window Motor Noise
- Engine Controls - MIL ON/DTC's P0131/P2251
- Fuel System - MIL ON/DTC's P0442/P0455/P0456
- Engine - Vibration At Cruising Speeds (55 MPH)
- Power Steering - High Steering Effort/MIL/DTC C1099
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456 Set
- Steering - In/Out Steering Wheel Play
- Interior - Seat Back Heater Inoperative
- A/T - Various Fluid Leaks
- Interior - Seat Heater Won't Warm Up Completely
- Steering - Steering Wheel Off Center, No Pull Or Drift
- Superceded Bulletins
- 0902812 - 08/10/12
- 0300210 - 06/30/10
- 0100611 - 02/03/11
- 0000309 - 01/12/09
- 0102906 - 07/28/06
- 0104709 - 10/16/09
- 0800309 - 05/07/09
- 0200104 - 01/15/08
- 0100308 - 02/07/08
- 0900507 - 02/15/07
- 0900806 - 03/17/06
- 0104107 - 10/03/07
- 0200507 - 08/29/07
- 0102207 - 06/08/07
- 0900306 - 01/26/06
- 0104606 - 11/09/06
- Lighting - Excessive Water/Condensation In Headlamps
- Lighting - Condensation In Front/Rear Lamps
- Lighting - Moisture In Front/Rear Lamps
- Instruments - Odometer Data Configuration Tip
- Instruments - Odometer Data Configuration
- Interior - Unable to Adjust Driver's Seat Manual Lift
- 0904108 - 12/19/08
- Interior - Seats Noisy/Shake Back And Forth When Braking
- Body - Paint Damage Repair Guide
- Interior - Avoiding Driver Floor Mat/Pedal Interference
- Body - Engine Under Cover Removal Precaution
- Audio System - SIRIUS(R) Radio System Activation
- Navigation System - Service Information
- Instruments - Navigation/Multi-Information Display Service Inf
- Restraints - Passenger Air Bag Deactivation Lamp ON
- Interior - Poor Dash Surface Appearance
- Suspension - Strut/Shock Replacement Guidelines
- Suspension - Strut/Shock Absorber Replacement Guidelines
- Suspension - Shock/Strut Replacement Guidelines
- Suspension - Front/Rear Suspension Squeak/Knock/Rattle
- Suspension - Front/Rear Knock/Rattle Noise On Bumps
- Suspension - Front/Rear Squeak/Knock on Bumps
- Electrical - Battery Testing Procedures
- Electrical - Battery Testing Procedure Requirements
- Electrical - Battery Testing/Charging Procedures
- Electrical - Battery Cover Removal Precautions
- Electrical - Battery Test Procedures
- Brakes - Noise/Judder/Dragging
- Brakes - Clunk/Bang On Initial Forward Take-Off
- A/T - Cooler/Line Flushing Procedure
- A/T - Cooler Line Flushing Procedure
- Engine - MIL ON With DTC P2006 Set
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456
- Engine Controls - MIL ON/DTC P2006 Set
- Engine Controls - Oxygen Sensor Removal Precautions
- Engine Controls - Oxygen Sensor Removal Precaution
- Engine Controls - O2, A/F Sensor Removal Precautions
- Exhaust System - Excessive Sulfur Odors
- Engine - Body Vibration at Cruising Speeds
- Engine - Crankshaft Pulley Service Precautions
- Engine - VVT Noise At Engine Start Up
- Body - Engine Undercover Hard to Remove
- A/T - Fluid Usage/Applications
- Tire Monitor System - Aftermarket Valve Stem Cap Usage
- Drivetrain - Drive Axle Clunking Noises
- Steering - Steering Wheel Is Off Center
- A/T - Correct Fluid Applications
- All Technical Service Bulletins
- Instruments - Navigation/Multi-Information Display Service Info
- Interior - Poor Upper Dash Surface Appearance
- Steering - Steering Wheel Off Center When Driving Straight
- Interior - Seats Shake/Make Noise When Braking
- Restraints - Passenger Air Bag Indicator (PAD) Information
- Electrical - Battery Maintenance Information
- Electrical - Battery Testing Procedures
- Drivetrain - Drive Axle Clunking Noises
- ABS/TCS/DSC - Clunk/Bang/Jolt From Front Of Vehicle At Take-Off
- Body - Paint Damage Repair Guide
- Exhaust System - Excessive Sulfur Odors
- Tire Monitor System - Warning Lamp ON/Low Tire Pressure
- Suspension - Front/Rear Knock/Rattle/Squeak On Bumps
- Engine - VVT Noise At Engine Start Up
- Steering/Suspension - Steering Wheel Off-Center
- Brakes - Judder/Dragging Diagnostic Information
- A/T - Cooler Line Flushing Procedures
- Tire Monitor System - Service Precaution
- Restraints - Air Bag Lamp ON/DTC B1881 Set
- A/T - Diagnostic Procedures
- Emissions - MIL ON/DTC's P2401/P2402/P2404 Stored
- Steering - EHPAS Technical Supplement
- Interior - Console Damage Prevention During Removal
- Audio System - iPod(R) Adapter Application Table
- Fuel System - Fuel Ethanol Content Testing
- Instruments - Info. Display Full Afetr Remote Start
- Computers/Controls KAM Memory Clearing After VVT R & R
- Navigation System - Beep Sound From Dash While Driving
- Audio System - Satellite Radio Serial Number Retrieval
- Engine - Drive Belt Squeal After Driving Through Water
- Wipers/Washers - Rain Sensor Initialization
- Mirrors - Door Mirror Glass Is Loose
- Tire Monitor System - Can't Turn OFF/On Reprogram
- M/T - 4th Gear Service Precautions
- Engine - Correct Oil Filter Wrench Applications
- A/C - Poor Blower Motor Performance
- Engine - Camshaft Timing Information
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Engine/Exhaust - Rattle Idling With A/T In Gear
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Body - Front End Pop Noise Over Bumps
- Engine/Body - Engine Undercover Removal Precautions
- Restraints - Air Bag Lamp ON/DTC's B2856/B104D/B2227
- Engine/Fuel - MIL ON/DTC P2006 Stored
- Electrical - Battery Maintenance
- A/C - Tracer Dye Usage Recommendations
- Ignition System - Spark Plug Removal/Installation
- Body - Wind Noise From Around Windows
- AT, Engine Controls - ECM/TCM Update
- Electrical - Battery Charging Precautions
- Air Bag System - Affect of Accessories On Air Bag Sys.
- Keyless Entry - Security Access Procedure
- Cooling System - Reconditioned Coolant Recommendations
- Campaign - Audio Unit Reprogramming for Satellite Signal
- Navigation System - Displays No or Incorrect Map
- Ignition System - Idle Fluctuation/Engine Vibration
- Engine - Front Crankshaft Bolt Service Precautions
- Wheels - Stain Prevention Information
- Engine Controls - Engine Stalling at Low Speeds
- Body - Uneven Clearance Between Liftgate & Rear Lamps
- Cooling System - Pre-Mixed Long-Life FL22 Coolant Info.
- Interior - C-Pillar Trim Deformed Upon Re-Installation
- Body - Rear Sliding Door Latch Screws Corroded
- Engine Controls - MIL ON/DTC P0128 Stored
- Engine Controls - Engine Stalls Driving at Low Speeds
- Engine Controls - Intermittent Engine Stumble
- Restraints - Seat Belt Retainers Broken
- A/T - Range Switch Removal/Installation Caution
- Navigation System - Displays Incorrect Map or No Map
- Steering - High Power Steering Effort
- Body - Wind Noise/Whistle From Outer Mirrors
- Computers/Controls - Module Reprogramming Precautions
- Engine - Oil Filter Element Replacement Precautions
- Audio System - Sirius Satellite Radio(R) Activation
- A/C - Control Unit Bulb Replacement
- Instruments - Configuring Odometer Data
- Cooling System - Small Water Pump Leak Explanation
- Engine - Unstable Idle/Engine Stalling
- Emissions - MIL ON/DTC P0441 Set
- Interior, A/C - Seat Heater Inspection Procedures
- Body - Rear Quarter Glass Replacement Precaution
- Body - Service Bumper Specification Change
- A/C - Unnecessary Parts Replacement Information
- Body - Engine Compartment Shroud Appearance
- Electrical - Battery Cover Removal Precaution
- Lighting - Plastic Headlamp Lens Maintenance Cautions
- Interior/Restraints - Seat Belt Buckle Rattles/Squeaks
- Engine - Component/Engine Replacement Guidelines
- A/C - Stops Cooling After Long Drive When Hot/Humid
- Suspension - Rear Trailing Link Bushing Availability
- Body - Sliding Door Lock Hard To Operate
- Engine - Noise Diagnostic Information
- Engine - Knocking Noise On Start Up/Shut Down
- Interior - Driver's Seat Chatters/Seat Lift Inoperative
- Interior - Front Seat Clunk Noise While Braking
- Interior - Leather Seat Squeaking Noises
- Interior - Front Seat Head Rest Rattling Noises
- Interior - Front Seat Back Squeaking Noises
- Interior - Squeaking Noise From Under The Driver's Seat
- Interior - Seat Trim Replacement Procedure
- Interior - Seat Back Squeaking Noises
- Body - Windshield Flaw/Scratch/Crack Information
- Engine - Engine Mount Bolt Torque Specification
- Keyless Entry - Remote Transmitter Is Inoperative
- Interior, A/C - Knob Comes Off Of R/H Dash Vent
- Body - Front Door Power Window Motor Noise
- Engine Controls - MIL ON/DTC's P0131/P2251
- Battery - Testing Information
- Fuel System - MIL ON/DTC's P0442/P0455/P0456
- Wipers/Washers - Wiper Blade Insert Replacement
- Tire Monitor System - Service Precautions
- Instruments - Odometer Write Deletion On M-MDS
- Engine - Vibration At Cruising Speeds (55 MPH)
- Power Steering - High Steering Effort/MIL/DTC C1099
- Engine Controls - O2 Sensor Removal Precautions
- Emissions - MIL ON/DTC's P0441/P0442/P0455/P0456 Set
- Recall 10V374000: Loss Power Steering Assist
- Steering - In/Out Steering Wheel Play
- Recall - Loss Of Power Steering Assist
- Interior - Seat Back Heater Inoperative
- A/T - Various Fluid Leaks
- Keyless Entry - Transmitter Battery Replacement Cautions
- Interior - Seat Heater Won't Warm Up Completely
- Fuel System - Ethanol Fuel Usage
- Suspension - Shock Absorber/Strut Replacement Guidelines
- Lighting - Condensation In Front/Rear Combination Lamps
- Lighting - Excessive Condensation In Headlamps
- Steering - Steering Wheel Off Center, No Pull Or Drift
- A/T - ATF Applications
- Interior - Proper Floor Mat Usage And Installation
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.