Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2004 Honda S2000 L4-2.2LFACTORY OEM SERVICE PROCEDURE
Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Body - Convertible Top Won't Work Properly
- Body - Convertible Top Cover Snap is Broken
- M/T - Pops Out of 1st or 2nd Gear
- Engine Controls - Hesitation on Hard Acceleration
- Emissions - MIL ON/Air Injection DTC's Set
- Body - Convertible Top Creaks/Pops or Rattles
- A/C - Whistling Noise From Passenger Side Vent
- M/T - Intermittently Pops Out of 4th Gear
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Superceded Bulletins
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- Campaign - Extension of The Vehicle Warranty
- 99-018 - 04/20/06
- Campaign - Vehicle Warranty Extension
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 01-077 - 01/12/05
- 01-023 - 09/01/02
- Campaign - Warranty Extension For Odometer Inaccuracy
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Body - Convertible Top Cover Snaps Broken
- Body - Deformed Windshield Moulding
- Body - Deformed Windshield Molding
- Body - Windshield Moulding is Deformed or Warped
- Audio System - Poor Reception Diagnostics Revision
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- 12-070 - 03/21/13
- Antitheft System - Immobilizer System (Type 2)
- Keyless Entry - Remote Transmitter Information
- Audio System - Revised Poor Reception Repair
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- 07-030 - 06/15/07
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- M/T - Pops Out of 4th Gear
- M/T - Intermittently Pops Out of 2nd Gear
- M/T - Intermittently Pops Out of Second Gear
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- Engine Controls - Control Module Programming Procedure
- Computers/Controls - Updating Modules/Control Units
- Computers/Controls - Updating Control Units And Modules
- Computers/Controls - Control Unit/Module Reprogramming
- Computers/Controls - Updating Modules/Control Units
- Engine Controls - Control Module Programming Procedure
- Vehicle - Recommended Materials
- Vehicle - Recommended Service Materials
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Steering - Vehicle Pulls/Drifts to the Left/Right
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Audio System - Poor AM/FM Reception
- Keyless Entry - Keyless Remote Transmitter Information
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- A/C - System Performance Testing
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine Oil Recommendations
- Engine - Falters/No Power/Won't Rev Over 7000 RPM
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- Exhaust System - Catalytic Converter Noise
- Driver's Air Bag - Replace Torx Bolts Properly
- Speedo/Odometer Read Excessive Speed and Distance
- Headlight Adjustments
- Suspension - Drifting and Pulling At Highway Speeds
- Suspension - Creak/Grunt From Rear At Low Speeds
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Air Fresheners - Bad News For Paint Or Plastic
- Nose Mask Installation Tips
- Wind Noise - Simple Way To Replicate
- Fuel Filler Cap Adapter Available For Testing Emissions
- Clearing DTCs and Setting ECM/PCM With The HDS
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Body - Convertible Top Won't Work Properly
- Body - Convertible Top Cover Snap is Broken
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- M/T - Grinding At Upshifts When Cold
- Popping From Front Wheel Upper Control Arm Mount
- Dashboard Switch Not Lit,? Replace Bulb, Not Switch
- Clutch Pedal Is Noisy or Feels Notchy
- Audio System - Never Play CD's With Adhesive Labels
- Paint - 2004 Paint Codes
- Ignition/Locks - Cutting Sidewinder-Type Keys
- M/T - Pops Out of 1st or 2nd Gear
- Engine Controls - Hesitation on Hard Acceleration
- Body - Plastic Body Clip Removal Tips
- Tires - Tubless Tire Repair Information
- Emissions - MIL ON/Air Injection DTC's Set
- Body - Convertible Top Creaks/Pops or Rattles
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Campaign - Vehicle Warranty Mileage Extension
- A/C - Whistling Noise From Passenger Side Vent
- M/T - Intermittently Pops Out of 4th Gear
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- Engine - Oil Cooler Center Bolt Torque Specification
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Antitheft - Immobilizer System (Type 2) Information
- Computers/Controls - Updating Control Units/Modules
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Cell Phone - Programmable HFL (HFT) Unit Update Info.
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.