Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2001 Ford Explorer ChassisFACTORY OEM SERVICE PROCEDURE
Electrical Component Locator: Motors
MOTORS LOCATION
| Component | Location |
|---|---|
| Air Suspension Control Compressor Assembly | Left rear of vehicle. |
| Blend Door Actuator | Behind right side of dash, top of A/C plenum. |
| Blower Motor (4.0L) | Right side of engine compartment. See Figure . |
| Blower Motor (5.0L) | Right side of engine compartment. See Figure . |
| Blower Motor (Rear) | In rear of center console. |
| Electronic Shift Motor Transfer Case | Attached to transfer case. |
| Liftgate Washer Pump | In liftgate washer reservoir. |
| Liftgate Wiper Motor | In liftgate. |
| Rear Air Door Actuator | In dash console. |
| Roof Opening Panel Motor | Center rear of roof. |
| Washer Pump Motor | In washer reservoir. |
| Wiper Motor (4.0L) | Left of center, at rear of engine compartment. See Figure . |
| Wiper Motor (5.0L) | Left of center, at rear of engine compartment. See Figure . |
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.