Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
1996 Ford Probe Base, AutomaticFACTORY OEM SERVICE PROCEDURE
Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Accessories Control Systems
- Air Bag, SRS
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Service Procedure Modification For Door Replacement (97-11-1)
- Air Bag Diagnostic Light Flashing - Fault Code 51 (96-25-4)
- Pop/Snap Noise Heard When Door Glass Is Cycled (96-17-1)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Cd4E - Harsh/Delayed Shifts After Transaxle Or TSS Replacement (02-2-4)
- Cd4E - No Forward Engagement - Forward Clutch CYLIND (00-18-2)
- Cd4E - Fluid Seeping From Vent Not Main Control (99-24-9)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- 2.0L Cd4E - Clearance Between SUBFRAME & Transaxle (98-23-11)
- Transmission Fluid Usage Chart (98-8-8)
- Harsh Shift &/Or Engagement - DTC 628 Or P0741 (97-4-6)
- Cd4E - Harsh Shift/Engagement - Codes 628 Or P0741 (96-26-14)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Fluid Leakage From Outer CV Joint Boot (96-25-16)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Cd4E - Service Units - Low Transmission Fluid (96-4-10)
- Cd4E With 2.0L - Direct Clutch Separator Plates (96-9-6)
- Cd4E - Whistle Noise At Operating Temperature (96-8-8)
- Cd4E - Alignment Tabs On Transaxle Chain Cover Pan (96-6-6)
- Auxiliary Emission Control Systems
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Mil On/DTC P0421 - No DRIVEABILITY Concerns (97-9-3)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Mil On/DTC P0421 - No DRIVEABILITY Concerns (97-9-3)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Headlights
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Lubrication System
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.5L - Tapping Noise From Rear Cylinder Head (97-17-13)
- 2.5L - Upper Engine Noises - Clatter/Tick/Tap/Knock (97-17-14)
- Fuel Economy - Customer Expectations (99-26-9)
- Buzz In Reverse/Clicking & Vibration On Right Turns (97-2-9)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- Mechanical - Hydraulic
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Sun Roof/T-Top/Convertible Top
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- DTC 181 Or P0171/Hesitation/Rough Idle/Power Loss (97-3-3)
- 2.0L - Mil On/DTC P0421 - No DRIVEABILITY Concerns (97-9-3)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.0L- Stalls/Runs Rough/Ticking From Lash Adjusters (96-21-3)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transfer Case
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- Cd4E - Harsh/Delayed Shifts After Transaxle Or TSS Replacement (02-2-4)
- Harsh Shift &/Or Engagement - DTC 628 Or P0741 (97-4-6)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Cd4E - Harsh Shift/Engagement - Codes 628 Or P0741 (96-26-14)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Water Leaks - Windshield Sealing - Service Tip (99-2-3)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Rattling/Buzzing Coming From Instrument Panel (98-2-9)
- Front Door Glass Adjustment Procedure For WINDNOISE (97-19-1)
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Pop/Snap Noise Heard When Door Glass Is Cycled (96-17-1)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.
Rather have a pro handle this?
A certified mobile mechanic comes to your home or office. They bring the tools, you stay comfortable. No tow truck, no waiting room, no surprises.
Comes to youSame-day available12-month warranty
Get a Free QuoteNo obligation. See pricing before you book.