Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2012 Chevrolet Orlando LS, Automatic TransFACTORY OEM SERVICE PROCEDURE
Power Steering System
- Specifications
- Schematic Wiring Diagrams
- Diagnostic Information and Procedures
- Diagnostic Code Index
- DTC C005B
- DTC C0176
- DTC C044A
- DTC C0456
- DTC C0475
- DTC C047A
- DTC C0545
- DTC C0565
- DTC C0569
- DTC C0710
- Symptoms - Power Steering System (Electronic Power Steering)
- Symptoms - Power Steering System (Hydraulic Power Steering)
- Variable Effort Steering Malfunction
- Power Steering System Test
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System (Hydraulic Power Steering)
- Rattle, Clunk, or Shudder Noise from the Power Steering System (Electronic Power Steering)
- Whine or Growl Noise from the Power Steering System (Electronic Power Steering)
- Whine or Growl Noise from the Power Steering System (Hydraulic Power Steering)
- Increase in Effort While Turning Steering Wheel
- Poor Return of Steering Wheel
- Steering Effort Hard or Too Easy in One or Both Directions (Electronic Power Steering)
- Steering Effort Hard or Too Easy in One or Both Directions (Hydraulic Power Steering)
- Repair Instructions
- Power Steering System Bleeding
- Checking and Adding Power Steering Fluid
- Power Steering Fluid Reservoir Replacement
- Power Steering Pump Pulley Replacement
- Power Steering Pump Replacement (1.6L LDE and 1.8L 2H0)
- Power Steering Pump Replacement (2.0L Diesel LNP)
- Steering Linkage Outer Tie Rod Replacement
- Steering Gear Boot Replacement
- Power Steering Fluid Reservoir Outlet Hose Replacement
- Power Steering Gear Inlet Pipe/Hose Replacement
- Power Steering Gear Outlet Pipe/Hose Replacement
- Steering Gear Replacement (Electronic Power Steering)
- Steering Gear Replacement (Hydraulic Power Steering)
- Steering Gear Bushing Replacement
- Steering Linkage Inner Tie Rod Replacement (Hydraulic Power Steering)
- Steering Linkage Inner Tie Rod Replacement (Electronic Power Steering)
- Power Steering Assist Motor Replacement
- Power Steering Control Module Calibration
- Description and Operation
- Special Tools and Equipment
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.