Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
2004 Chevrolet SSRFACTORY OEM SERVICE PROCEDURE
Electrical Component Locator: Motors
MOTORS LOCATION
| Component | Location |
|---|---|
| Air Temperature Actuator | Behind radio, top of HVAC case. See Figure . |
| Blower Motor | Lower right side of dash. See Figure . |
| Cooling Fan | Front center of engine. See Figure . |
| Door Latch Assembly (Driver) | Rear of driver door. See Figure . |
| Door Latch Assembly (Passenger) | Rear of passenger door. See Figure . |
| Folding Top Outer Latch Actuator | Center of, above inside rearview mirror. See Figure . |
| Folding Top Pump Motor Assembly | In center bottom of roof stowage compartment. See Figure . |
| Fuel Pump & Sender Assembly | Inside fuel tank. See Figure . |
| Mode Actuator | Left side of dash on HVAC case. See Figure . |
| Rear Compartment Lid Release Switch/Actuator (Exterior) | Under left rear of vehicle. See Figure . |
| Recirculation Actuator | Right side of dash on HVAC case. See Figure . |
| Recirculation Actuator | Right side of dash, above blower motor. See Figure . |
| Sear Rear Vertical Motor (Driver) | Under driver seat. See Figure . |
| Seat Front Vertical Motor (Driver) | Under driver seat. See Figure . |
| Seat Horizontal Motor (Driver) | Under driver seat. See Figure . |
| Seat Horizontal Motor (Passenger) | Under passenger seat. See Figure . |
| Starter | Right side of engine. See Figure . |
| Throttle Actuator Control (TAC) Module | Left rear of engine compartment. See Figure . |
| Window Motor (Driver) | Driver door. See Figure . |
| Window Motor (Passenger) | Passenger door. See Figure . |
| Windshield Washer Fluid Pump | On washer fluid reservoir. See Figure . |
| Windshield Wiper Motor | Near center of front cowling. See Figure . |
Factory Service Tools
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Disclosure: Verified tool recommendations may earn an affiliate commission at no cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.
Rather have a pro handle this?
A certified mobile mechanic comes to your home or office. They bring the tools, you stay comfortable. No tow truck, no waiting room, no surprises.
Comes to youSame-day available12-month warranty
Get a Free QuoteNo obligation. See pricing before you book.