Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSBMW2009335DREPAIR AND DIAGNOSISSTEERINGPOWER STEERINGSTEERING AND WHEEL ALIGNMENT - REPAIR
2009 BMW 335d
Steering And Wheel Alignment - Repair
2009 BMW 335dSECTION Steering And Wheel Alignment - Repair
- 3200 Electronic chassis alignment
- 3200620 Adjusting rear axle
- 3200610 Adjusting toe-in and camber on front axle
- 3210005 Adjustment for active front steering
- 6131996 Carrying out steering angle sensor adjustment
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 3100... Front axle steering: wheel/chassis alignment check must be carried out after the following work
- 3200... General chassis and suspension definitions
- 3200... General information and definitions
- 3200... Identification of suspension without label
- 3200... Identifying suspension from label on front axle
- 3200... Information on replacing steering gear after accident damage
- 3200155 KDS chassis/wheel alignment check with ride height measurement without vehicle load
- 3200150 KDS chassis/wheel alignment check with vehicle load up to design position
- 3200... Moving vehicle into design position
- 3200... Moving vehicle into normal position
- 32... Overview of steering
- 32...... Overview of steering wheel/casing components
- 3200... Performing rim runout compensation
- 00...... Raising vehicle with trolley jack
- 3300... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 3200... Test conditions for chassis/wheel alignment check
- 3211 mechanical steering gear
- 3200... Information on replacing steering gear after accident damage
- 3211... Notes on checking steering backlash on vehicles with rack-and pinion steering (with front axle raised)
- 3211... Replacing gaiter for electric steering gear (EPS) on left or right
- 3211100 Replacing gaiter for steering gear on left or right
- 3213 steering gear with servo unit
- 3213006 Bleeding power steering unit
- 3200... Information on replacing steering gear after accident damage
- 3213070 Removing and installing (replacing) electric steering gear (EPS)
- 3213065 Removing and installing/replacing active front steering power steering gear
- 3213060 Removing and installing/replacing power steering gear
- 3211... Replacing gaiter for electric steering gear (EPS) on left or right
- 3221 steering arms, tie rods, steer. damper
- 3231 steering column
- 3231020 Removing and installing/replacing lower section of steering column trim
- 3231070 Removing and installing/replacing lower section of steering spindle
- 3231082 Removing and installing/replacing steering angle sensor
- 3231090 Removing and installing/replacing steering column
- 3231003 Removing and installing/replacing upper section of steering column trim
- 3231241 Replacing adjusting lever for steering column
- 3231102 Replacing steering spindle sleeve
- 3233 steering wheel
- 3234 steering wheel for airbag
- 6577... Notes on scrapping BMW vehicles with gas generators (central airbag control unit, airbag system)
- 7212... Procedure after airbag triggering as result of an accident
- 3234020 Removing and installing/replacing airbag unit
- 3234030 Removing and installing/replacing airbag unit (sport steering wheel)
- 7200... Safety regulations for handling components with gas generators
- 3241 pump and oil supply
- 3213006 Bleeding power steering unit
- 3241... Instructions for removing and installing ear clips
- 3241... Instructions for using special tool 32 4 000
- 3241... Notes on hydraulic line with quick-connect coupling
- 3241033 Removing and installing (replacing) power steering pump for power steering gear with active front steering
- 3241253 Removing and installing/replacing fluid reservoir for power steering with active front steering
- 3241100 Removing and installing/replacing belt pulley on vane pump for hydraulic steering
- 3241250 Removing and installing/replacing fluid reservoir for power steering
- 3241060 Removing and installing/replacing vane pump for power steering (M57T2 335d)
- 3241341 Replacing cooler return line for power steering
- 3241332 Replacing pressure line for power steering (M57T2 335d)
- 3241351 Replacing return line for power steering (M57T2 335d)
- 3241311 Replacing suction line for power steering (M57T2 335d)
- 3243 Electronic power steering
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.